Page 1 PIONEER CORPORATION 1-1, Shin-ogura, Saiwai-ku, Kawasaki-shi, Kanagawa 212-0031, Japan PIONEER ELECTRONICS (USA) INC. P.O. Box 1760, Long Beach, CA 90801-1760, U.S.A. PIONEER EUROPE NV Haven 1087, Keetberglaan 1, 9120 Melsele, Belgium PIONEER ELECTRONICS ASIACENTRE PTE. LTD. 253 Alexandra Road, #04-01, Singapore 159936...
Page 2: Safety Information
PIONEER Service Manual. A subscription to, or additional copies of, Also test with plug reversed Earth PIONEER Service Manual may be obtained at a nominal (Using AC adapter ground charge from PIONEER. plug as required)
Page 3: Table Of Contents
10.4 DAC HIGH ASSY (1/2) ............................... 96 10.5 DAC HIGH ASSY (2/2) ............................... 98 10.6 FRONT HDMI USB ASSY ............................100 10.7 USB RECT ASSY and MULTI CH IN ASSY (SC-68)....................102 10.8 USB DAC ASSY (SC-68)............................104 10.9 DIGITAL MAIN ASSY (1/11) ............................. 106 10.10 DIGITAL MAIN ASSY (2/11) ...........................
Page 4 10.48 FRONT BRIDGE ASSY ............................175 10.49 DISPLAY BRIDGE ASSY ............................176 10.50 F-IN BRIDGE ASSY..............................177 10.51 MCH BRIDGE ASSY (SC-68) ..........................178 10.52 A REG BRIDGE ASSY............................179 10.53 MIC HP GUARD, FAN CONNECT, BIND DM CABLE and BIND B CABLE ASSYS ..........180 10.54 FFC GUARD, VREG GUARD and PANEL GUARD ASSYS ...................181...
Page 5: Service Precautions
IC with heat-pad IC9002 1st DSP ------------------- IC with heat-pad IC9203 LAN PHY ------------------- IC with heat-pad AWX9904 IC9204 MEDIA PROCESSOR ------------------- (SC-68) DIGITAL MAIN AWX1198 IC9510 REGULATOR ------------------- IC with heat-pad ASSY (SC-67) IC9520 REGULATOR ------------------- IC with heat-pad...
Page 6: Notes On Assembling
BIND DM CABLE ASSY Accessory of Panel Base D AMP ASSY Rear Panel If a screw at any of these points needs to be removed for service, be sure to check that the swarf is not on the screw before refastening. SC-68...
Page 7: Specifications
Continuous average power output* 8 Ω ..........................140 W** per channel 6 Ω ..................190 W (SC-68)*** / 180 W (SC-67)*** per channel * Measured pursuant to the Federal Trade Commission’s Trade Regulation rule on Power Output Claims for Amplifiers ** 1 kHz with no more than 0.08 %**** total harmonic distortion...
Page 8 HDMI input/MHL terminal ......................... 5 V, 1 A USB terminal................... USB2.0 High Speed (Type A) 5 V, 2.1 A USB terminal (SC-68 only)..................USB2.0 High Speed (Type B) iPod terminal ......................USB, and Video (Composite) ADAPTER PORT terminal ......................... 5 V, 100 mA WIRELESS LAN ADAPTER terminal ....................
Page 9 The AirPlay logo is a trademark of Apple Inc.  Windows and the Windows logo are trademarks of the Microsoft group of companies.  MHL, the MHL Logo, and Mobile High-Definition Link are trademarks or registered trademarks of MHL LLC in the United States and other countries. SC-68...
Page 10: Basic Items For Service
Disturbed image (video jumpiness) Volume too high Too dark Volume fluctuating Mottled color Cleaning Before shipping out the product, be sure to clean the following positions by using the prescribed cleaning tools. Name Cleaning paper Refer to “9.4 CHASSIS SECTION”. SC-68...
Page 11: Pcb Locations
AUDIO ASSY SC-67/UXJCB: PRIMARY SHIELD ASSY COMPONENT ASSY BUFFER GND ASSY D AMP ASSY INTERFACE ASSY MULTI CH IN ASSY (SC-68/UXJCB only) CONNECT ASSY DISPLAY BRIDGE ASSY MCH BRIDGE ASSY (SC-68/UXJCB only) VREG GUARD ASSY IR INTERFACE_M ASSY FB-CONNECT ASSY...
Page 12 Therefore, when replacing, be sure to use parts of identical designation. Mark No. Description Part No. Mark No. Description Part No. LIST OF ASSEMBLIES 1..INTERFACE REG ASSY (SC-67) AWR7155 1..D AMP ASSY (SC-68) AWH7052 2..INTERFACE ASSY AWX1172 2..D AMP ASSY AWX1214 2..IR REG ASSY AWX1173 2..B DIODE ASSY...
Page 13: Jigs List
Diagnosis for DIGITAL MAIN ASSY, DAC HIGH ASSY 28P + 14P board to board extension jig cable GGD1763 Diagnosis for DAC HIGH ASSY [2] Lubricants and Glues List Lubricants and Glues No. Name Remarks Silicone Grease ZLB-PN397B Refer to “9.5 FRONT SECTION” SC-68...
Page 14: Block Diagram
6.XTEMPSD5 15.GNDD 4.XUSBERR COMPOSITE ASSY 7.XDCERR 14.RYAF 1.V-5_V 3.D+ 1/11 - 8.GNDD 2.GNDV 13.RYCR 2.D- 12.RYFH 9.GNDD 3.V+5_V (SC-68 : AWX1125) 1.GNDD 11.RYB 10.12VTRG1 4.GNDV 11.12VTRG2 10.XBERR 5.ZONE3_OUT 1.GNDD DIGITAL MAIN AS 12.12VERR 9.XTEMPSD5 16.OSDSCK 6.GNDV (SC-67 : AWX1126) 2.Y_IN 13.RF_POW...
Page 15 SC-LX86 ATS7449-A FU62 ADG7121-A 2.GND SC-LX76 ATS7440-A 1.+B ADX7755- 4/375 Y0020 S2,S3,S9 E ASSY D-DAC BRIDGE ASSY USB-DAC ASSY (AWX1128) (SC-68 : AWX1097) CN7201 FU14 FU13 FU15 FU11 FU12 CN3784 CN3782 1.V+12_DF CN9002 CN9003 2.GND_DF IR REG ASSY 3.V-12_DF 1.USBDPON 4.GND_DF(S)
Page 16: Block Diagram For Audio Block
4.2 BLOCK DIAGRAM FOR AUDIO BLOCK • SC-68 SC-68...
Page 17 SC-68...
Page 18 • SC-67 SC-68...
Page 19 SC-68...
Page 20: Block Diagram For Digital Main Video Block
COMPONENT Analog Devices "ADV7181C" IC909 COMPONENT ASSY 24MHz 25MHz 36.864MHz Media Processor BRIDGE CO "DM860A" LAN PHY Gate Array SMCS SEIKO EPSO ETHERNET "LAN8700" "PE7008A" IC9204 IC9203 IC603 SDRAM-166 iPod 256Mb(16Mx16) Authentication IC IC9201 "341S2162" IC9206 FLASH ROM IC9205 SC-68...
Page 21 22.5792MHz 24.576MHz 864MHz 20MHz 20MHz 1st DSP 2nd DSP Gate Array D808K013CPTP400 D808K013CPTP400 SEIKO EPSON IC9002 IC9702 "PE7008A" C603 SDRAM-166 SDRAM-166 SeriFlash SeriFlash 64Mb(8Mx16) 64Mb(8Mx16) 16Mb 16Mb IC9004 IC9001 IC9703 IC9701 cation IC S2162" POWER SUPPLY BLOCK Diagram (DCDC,LDO) SC-68...
Page 22: Block Diagram For Digital Main Audio Block
SEL (LCX157) DIGITAL MA IC1814 AND (SZ08) NBCK IC1804 NLRCK XXTL0 (VHC126) FD/DSDFL 24.576MHz IC1806 DSDFR IC9204 NETDSDMC (VHC126) NBCK SC-68 only IC1509 ×8 DIRMCK 22.5792MHz USB DAC USBDMCK ASSY NETMCK (VHCT126) HDMI IC1613 SEL (LCX157) HDMCK MSPDIF Port HDSPDIFP...
Page 23 IC9702 2nd DSP D808K013CPTP400 20.0MHz AHCLKR0 DVCPOW ACLKR0 AFSR0 AXR0[0] AHCLKX0 AHCLKR1 ACLKX0 I2S-C/LFE ACLKR1 AFSX0 AFSR1 AXR0[7]D2FDT D1FDT AXR1[0] AXR0[8]D2CDT I2S-SURR D1CDT AXR1[1] AXR0[9]D2SDT D1SDT AXR1[2] AXR0[10]D2BWDT D1BWDT AXR1[3] AXR0[12]D2HWDT D1HWDT AXR1[4] I2S-SRB/HEIGHT AXR0[13] D1DMDT AXR1[5] AMUTE I2S-FW/-- SC-68...
Page 24: Block Diagram For Composite Video Block
4.5 BLOCK DIAGRAM FOR COMPOSITE VIDEO BLOCK SC-68...
Page 25: Block Diagram For Component Video Block
4.6 BLOCK DIAGRAM FOR COMPONENT VIDEO BLOCK SC-68...
Page 26: Block Diagram For Power Block (1)
4.7 BLOCK DIAGRAM FOR POWER BLOCK (1) SC-68...
Page 27 SC-68...
Page 28: Block Diagram For Power Block (2)
4.8 BLOCK DIAGRAM FOR POWER BLOCK (2) SC-68...
Page 29 SC-68...
Page 30: Diagnosis
Check DISPLAY ASSY Replace DISPLAY ASSY C3021 +3.3V or replace IC3003 Replace DISPLAY ASSY Check DISPLAY ASSY X3001 doesn't X3001 oscillating oscilate Replace X3001 Replace IC3001 Check DISPLAY ASSY Replace DISPLAY ASSY IC3001 8 pin +5V or replace IC3002 (XRESET) SC-68...
Page 31 Check the circuits arround RY71 or replace PRIMARY ASSY when press power key? Check DVCPOW signal path Check DIGITAL MAIN ASSY CN601 13 pin (DVCPOW) DISPLAYDISPLAY BRIDGE DIGITAL MAIN ASSY LH when press power key? Diagnose or replace DIGITAL MAIN ASSY SC-68...
Page 32 Check FL AC1, 2 power supply V3301 1-62 pin 4.3Vac ? path or replace DISPLAY ASSY Check DISPLAY ASSY Replace X3201, IC3201 or DISPLAY X3201 oscillating ASSY Diagnose arround IC3201 or replace V3301(FL Display) damage ? DISPLAY ASSY Replace V3301 SC-68...
Page 33 SP system setting.) Zone3 Audio no output Digital inoutput Refer to speaker (front is OK) flow. Analog inoutput from Zone 3 line from Zone 3 line out? (MAIN is OK) Which channels correspond to zone, refer to instruction manual. SC-68...
Page 34 Cable from FRONT HDMI USB Assy Diagnose DIGITAL MAIN ASSY MEDIA SERVER in (arround IC9204,IC9203) (Other Digital OK) or replace DIGITAL MAIN ASSY SC-68 only USB DAC in  Diagnose USB DAC ASSY Diagnose or replace (Other Digital OK) (arround IC5503,IC5512,X5501,X5502,...
Page 35 "Pure Direct", Replace IC2501 Check the analog signal path Other results Dignose and repair NG point e.g. if selecting "CD", check INL11 58 pin / INR11 57 pin, outputs is FROUT 8 pin / FLOUT 7 pin SC-68...
Page 36 Continue the following flow or replace DAC HIGH ASSY Diagnose NG part of DAC HIGH ASSY DA part (MAIN) around IC2011-2014,2017 DA part (zone 2) arround IC2471 AD part arround IC2431 DIR part arround IC2001 SC-68...
Page 37 2 Component out? Diagnose or replace HDMI inHDMI out? DIGITAL MAIN ASSY Diagnose or replace HDMI in DIGITAL MAIN ASSY HDMI Zone4 out? Composite Diagnose or replace (Component) in DIGITAL MAIN ASSY HDMI out? Diagnose or replace GUI? DIGITAL MAIN ASSY SC-68...
Page 38 Diagnose INTERFACE ASSY Remote Control (IR,SR circuits) or replace INTERFACE ASSY Check the signal path of Repair or replace IR-IN,SR-IN,RMC INTERFACECONNECT NG point DIGITAL MAINDISPLAY BRIDGEDISPLAY ASSY No problem Diagnose DISPLAY ASSY (IR,SR,RMC signal path, arround U3201) or replace DISPLAY ASSY SC-68...
Page 39: Circuit Description
BERR port becomes "L". Refer to “How to Enter MCACC LED failure (IC3001 84pin) Release Mode” . detection [How to Enter Release Mode] During Standby mode, simultaneously press and hold the "TUNE [] " and "MULTI-ZONE ON/OFF" keys for 5 seconds. SC-68...
Page 40 *R4110 R4170 R4167 Q4108 1k 1% 2SC4154-11(EF) GND_TP GND_TP GND_TP DIGITAL MAIN DISPLAY INTERFACE ASSY ASSY ASSY CN3001 CN7902 CN7901 CN601 CN603 CN7801 CN7804 CN7004 CN7006 XTEMSD5 AMPTEMP UCOM CN602 CN7802 CN7803 CN7003 IC3001 DISPLAY BRIDGE CONNECT ASSY ASSY SC-68...
Page 41 IC4301 IC4501 IC4901 IC4302 IC4502 IC4902 GNDS V-5VFILT2 VSS+12V R4147 R4104 R4146 R4140 ACN7165-A R4109 DIGITAL MAIN INTERFACE DISPLAY ASSY ASSY ASSY CN7902 CN7901 CN601 CN603 CN7801 CN7804 CN7004 CN7006 CN3001 XDCERR UCOM IC3001 CONNECT DISPLAY BRIDGE ASSY ASSY SC-68...
Page 42 GNDS V-5VFILT2 IC4301 IC4501 IC4901 IC4302 IC4502 IC4902 VSS+12V R4147 R4104 R4146 R4140 ACN7165-A R4109 DIGITAL MAIN INTERFACE DISPLAY ASSY ASSY ASSY CN3001 CN7902 CN7901 CN601 CN603 CN7801 CN7803 CN7003 CN7006 XOLERR UCOM IC3001 CONNECT DISPLAY BRIDGE ASSY ASSY SC-68...
Page 43 GND_B GND_B 100k D4021 R5023 R5039 2125 2125 2.2k RKZ18KG(B2) C4051 330p/50 Q4025 2SC4154-11(EF) V-64V DIGITAL MAIN DISPLAY INTERFACE ASSY ASSY ASSY CN3001 CN7902 CN7901 CN601 CN603 CN7801 CN7804 CN7004 CN7006 XBERR UCOM IC3001 DISPLAY BRIDGE CONNECT ASSY ASSY SC-68...
Page 44 4.1V or lower Power ON detection and XVDDERR port is set to "L" XVDDERR Circuit FRONT HDMI USB ASSY V+5_USB_DC DISPLAY ASSY V+5EV CN8002 CN3004 UCOM IC3001 Q8004 2SC4154-11(EF) GNDU GNDCH SC-68...
Page 45 XMHLPERR port is MHL equipment is set to "L". acknowledged after second power-on. XMHLPERR Circuit FRONT HDIM USB ASSY V+5_MHL CN8002 XMHLPERR V+5_USB_DC DIGITAL MAIN ASSY DISPLAY ASSY V+3R3_E CN3004 CN3001 CN601 IC101 R3161 R742 R263 GNDD SC-68...
Page 46 [4] Error Indications SC-68...
Page 47 SC-68...
Page 48: Service Mode
[ ↑ ] [↓] Display number of times D E R R Digital Power abnormality is detected. [ ↑ ] [↓] Display number of times B REG power supply B E R R failure is detected. [ ↑ ] [↓] SC-68...
Page 49 1 kHz square wave. If the square wave is output, ↓ 5 sec the CEC line is considered to be normal. Power OFF (All zone OFF) FAN TEST : The function for making the FAN to be forced to rotate. SC-68...
Page 50: Disassembly
Before turning the unit ON, be sure to ground the marked points with the Chassis 68. Or, you may short-circuit the ground points on the solder surface, using pieces of wire. Screws for Rear Panel ABA1011 ABA1207 ABA7078 BPZ30P100FTC BMZ30P040FTB BPZ30P080FTB CBZ30P080FTB SC-68/UXJCB only F F F F F F SC-68...
Page 51 Double Side Tape (10 x 110mm). JA8003 Notes on assembling CN8001 ∗3: PCB binder tilt in the direction of the blue arrow. ∗3 ∗4: 15P FFC (ADD7745) don't touch cable from FRONT HDMI USB ASSY Power Transformer. Front MIC HP ASSY SC-68...
Page 52 Front ∗11: Twist the PCB binders around the 5P 5P Housing ASSY Housing ASSY (ADX7786) and tilt in the direction of the blue arrow, so that it don’t contact the Diode and the Bonnet 68. Diode ∗11 ∗11 Front SC-68...
Page 53 HDMI Cable to prevent a load from being applied to the HDMI connector. Always connect the HDMI Cable because FRONT HDMI USB ASSY the iPod iPhone iPad LED blinks, which Front causes a shutdown, if the power is turned on without the cable connected. SC-68...
Page 54 ∗8: Pass the cable (ADX7791: from PRIMARY ASSY) under the REG ASSY. Front ∗9: PCB binder tilt in the direction of the blue Screwdriver PRE BRIDGE ASSY arrow. PRIMARY ASSY REG ASSY ∗8 ADX7791 BIND DM CABLE ASSY ∗9 ADX7791 Front SC-68...
Page 55 (3) Connect the Rear Panel to the Chassis 68 Ground and GND point of the D AMP ASSY. (Refer to the “Ground Points” for the GND point of the D AMP ASSY.) Insulation Sheet D AMP ASSY Chassis 68 SC-68...
Page 56 Always connect the HDMI Cable because CN7801 the iPod iPhone iPad LED blinks, which causes a shutdown, if the power is turned 20P + 14P board to board on without the cable connected. CONNECT ASSY extension jig cable (GGD1798) SC-68...
Page 57 ∗1: After the cable is bounded, pull the extra length to the direction indicated by the blue arrow. Front (5) Disconnect the two connectors. (6) Remove the FRONT BRIDGE ASSY from the two PCB Holder, using Pliers. Pliers FRONT BRIDGE ASSY FB-CONNECT ASSY PCB Holder Front SC-68...
Page 58 IR INTERFACE_M ASSY may be loosened. Attach the connectors securely. D AMP ASSY Front Rear Panel [3-2] Diagnosis (1) Temporarily attach the IR Cover 85 to the Rear Panel , using the three screws. (ABA1011) IR Cover 85 SC-68...
Page 59 (Refer to the steps (11) to (7) of PRIMARY ASSY “[2-2] Diagnosis”) (3) Remove the IR INTERFACE_M ASSY. (4) Disconnect the five connectors. Chassis 68 IR INTERFACE_M ASSY CN4001 CN4004 CN4002 CN4003 D AMP ASSY Front 19P FFC D AMP ASSY CN7006 INTERFACE ASSY Front SC-68...
Page 60 (11) Remove the 19P FFC (ADD7747) by disconnect the connector. D AMP ASSY Note on assembling : To attach the D AMP ASSY in the correct position, refer to the “[1] Attach the D AMP CN4000 ASSY” of “Assembling of Digital Amplifier Block”. SC-68...
Page 61 (8) Remove the D-AUDIO BRIDGE ASSY. 5P Housing ASSY Note on assembling ∗4: Twist the PCB binder around the 5P Housing Screwdriver ∗4 ASSY (ADX7786) so that it don’t contact the Bonnet 68. D-AUDIO BRIDGE ASSY D-DAC BRIDGE ASSY DAC HIGH ASSY Front SC-68...
Page 62 Case of SC-67: Remove the PRIMARY SHIELD ASSY. DIGITAL MAIN ASSY (16) Unhook the hook. (17) Disconnect the connector and then remove the DIGITAL MAIN ASSY (SC-68 only: with the D MAIN Shield 85). SC-68 only (18) Remove the four screws. (BBZ30P060FCC) (19) Remove the two Nylon Rivet.
Page 63 (DIGITAL MAIN CN603 <-> CONNECT CN7801) (9) Connect the 27P board to board extension jig cable. (GGD1799) CN7802 (COMPONENT CN8301 <-> DIGITAL MAIN CN901) CN7801 CN8301 COMPONENT ASSY 20P + 14P board to board CONNECT ASSY extension jig cable (GGD1798) SC-68...
Page 64 Bonnet 68. A-DAC BRIDGE ASSY D-DAC BRIDGE ASSY Front AC inlet (4) Remove the screw. (SC-68 only : BMZ30P040FTB) (5) Remove the four screws. (BPZ30P080FTB) (6) Remove the AC inlet by removing the two screws. (CBZ30P080FTB) (7) Remove the five screws. (ABA1011) SC-68 only (8) Cut the Binder.
Page 65 (12) Remove the Push Rivet. (SC-68 only: SC-68 : USB DAC ASSY AEC7071) SC-67 : PRIMARY SHIELD ASSY (13) Remove the Push Rivet. (AEC7071) (14) Case of SC-68: Disconnect the connector and then remove the USB DAC ASSY. SC-68 only Case of SC-67: Remove the PRIMARY SHIELD ASSY.
Page 66 ( Refer to the “[3] D AMP ASSY” of “Disassembly” ) ----------------------------------------------------------------- (1) Allocate the D AMP ASSY attached with the D AMP ASSY Heat Cond Sheet, the Heat Sink Spacer, the Heat Sink 85 and the 19P FFC (ADD7747). Don’t fix it with screws. SC-68...
Page 67 Note: The screw at position ∗1 cannot be unscrewed using a usual screwdriver because it touch a capacitor in the REG ASSY. Attach and secure it using a screwdriver with a short grip. REG ASSY D AMP ASSY Short grip screwdriver SC-68...
Page 68 (ABA1011) Note: Fix the DIGITAL MAIN ASSY to the Hook of the Right Angle 85. DIGITAL MAIN ASSY Hook Right Angle 85 Front (4) Temporarily attach the IR Cover 85 to the Rear Panel, using the two screws. (ABA1011) SC-68...
Page 69 (3) and (4). (ABA1011) (7) Remove the Rear Panel (with other ASSY). IR Cover 85 (8) Attach the four screws. (AMZ30P060FTC) Refer to the step (6) to (1) of “[3-1] Remove the IR Cover” of “Disassembly” henceforth. IR Cover 85 SC-68...
Page 70: Each Setting And Adjustment
• Q4501,4502 ( IRF6775MPBF • Q4601,4602 ( IRF6775MPBF • Q4701,4702 ( IRF6775MPBF • Q4801,4802 ( IRF6775MPBF IRF6775MPBF • Q4901,4902 ( DISPLAY ASSY After replacing IC3001(PDC203A8), perform "8.3 REGION WRITING" and then, update to the latest firmware. Other assemblies No adjustment required SC-68...
Page 71: How To Save And Load The Setting Using Backup Function With Usb Memory
No setting file Mismatching between the setting file and the specification of the A/V RECEIVER type to be loaded back Error due to Checksum, Signature Check, and Size Check Ejecting of USB device (during reading of the setting file) SC-68...
Page 72: Region Writing
S C - 6 8 / U X J C B Region Writing finished 5. Pull out the AC cord. [Cautions] Writing of destination is not completed until the BridgeCo software starts. It takes about 45 seconds before the BridgeCo software starts. SC-68...
Page 73: How To Update Firmware
3. Connect the USB Memory to the USB terminal (A type) of the front panel. [Procedures] 1. While holding down "TUNE↑" key on the front panel, press "STANDBY ON/OFF" key and moves to the UPDATE PANEL mode. 2. The updating process is as follows. SC-68...
Page 74 Update Confirmation U P D A T E [PRESET ← ] [←] [→] Update Confirmation U P D A T E Y E S [ENTER] File searching A c c e s s i n g UPDATE FILE searching completed SC-68...
Page 75 Time required for updating varies, because only the programs that require updating will be updated. [Confirmation] Enter UPDATE PANEL mode and check that the programs have been updated. [Cautions] You cannot perform an update until the BridgeCo software starts. It takes about 45 seconds before the BridgeCo software starts. SC-68...
Page 76: Exploded Views And Parts List
Screws adjacent to b mark on product are used for disassembly. For the applying amount of lubricants or glue, follow the instructions in this manual. (In the case of no amount instructions, apply as you think it appropriate.) 9.1 PACKING SECTION SC-68/UXJCB only SC-67/UXJCB only SC-68...
Page 77 13 Remote Control Unit MSW AXD7668 NSP 14 Dry Cell Battery (R3) VEM1051 15 AM Loop Antenna XTB3004 (2) CONTRAST TABLE SC-68/UXJCB and SC-67/UXJCB are constructed the same except for the following: SC-68/ SC-67/ Mark No. Symbol and Description UXJCB UXJCB...
Page 78: Exterior Section
FRONT HDMI USB ASSY CN8001 D AMP ASSY CN4001 FRONT HDMI USB ASSY JP8001 C´ D´ MIC HP ASSY CN3472 INTERFACE ASSY DISPLAY ASSY CN7008, CN7005 Double side Refer to JP3001 tape 10 x 110mm “9.5 FRONT SECTION” DISPLAY ASSY CN3001 SC-68...
Page 79 ANG7684 18 Top Beam 85 ANG7726 19 PCB Mold AMR2533 20 Insulator AMR7198 (2) CONTRAST TABLE SC-68/UXJCB and SC-67/UXJCB are constructed the same except for the following: SC-68/ SC-67/ Mark No. Symbol and Description UXJCB UXJCB > 9 Power Transformer...
Page 80: Rear Section
9.3 REAR SECTION SC-68/UXJCB only SC-68/UXJCB only SC-68/UXJCB SC-67/UXJCB only only A REG BRIDGE ASSY CN5775 Power Acetate Tape Transformer REG ASSY CN7603 Refer to “9.4 CHASSIS SECTION” SC-68...
Page 81 23 Right Angle 85 ANG7687 24 D MAIN Shield 85 See Contrast table (2) NSP 25 PCB Spacer AEC1084 (2) CONTRAST TABLE SC-68/UXJCB and SC-67/UXJCB are constructed the same except for the following: SC-68/ SC-67/ Mark No. Symbol and Description UXJCB UXJCB...
Page 82: Chassis Section
Panel Base Accessory of Panel Base Power Power Transformer Transformer IR REG ASSY CN7241 IR REG ASSY CN7271 IR REG ASSY FAN CONNECT CN7251 ASSY CN5932 IR REG ASSY CN7281 B-DIODE ASSY CN7401 COMPONENT ASSY JP8402 Cleaning paper GED-008 SC-68...
Page 83 23 Trans Frame 85 ANG7685 24 Center Beam 85 ANG7689 25 PCB Mold AMR2533 (2) CONTRAST TABLE SC-68/UXJCB and SC-67/UXJCB are constructed the same except for the following: SC-68/ SC-67/ Mark No. Symbol and Description UXJCB UXJCB 1 D AMP ASSY...
Page 84: Front Section
Note ∗2: Please tape up at four (4) places to protect Panel Base 55U as shown on the photograph when you remove the Panel. Left side Right side Note ∗3: Double Side Tape (10mm x 30mm) affixing Center line position on Panel +0mm -1.5mm Inside SC-68...
Page 85 18 Door Base 85 AMR7565 19 Door Panel 57U ANB7562 20 Damper ASSY (240) LX AXA7156 (2) CONTRAST TABLE SC-68/UXJCB and SC-67/UXJCB are constructed the same except for the following: SC-68/ SC-67/ Mark No. Symbol and Description UXJCB UXJCB 29 Panel...
Page 86: Schematic Diagram
DAC OUT<-> PRE OUT R3992 J2501 AKB7242-A AKB7246-A pattern A J2502 AKB7243-A AKB7247-A R3993 J2503 AKB7234-A AKB7233-A GNDA J2504 AKB7242-A AKB7246-A R3995 HP<-> J2505 AKB7243-A AKB7247-A ZONE OUT R3996 : Audio Signal Route pattern A GNDA GNDA CN7671 SC-68...
Page 87 AUDIO ASSY (1/3) (SC-68 : AWX1119) (SC-67 : AWX1122) CN3794 C2827 10u/50 C2826 10u/50 AGND6 INL2 INR13/FRIN2 INR2 INL13/FLIN2 INL1 R3018 CN2503 INR14/SRIN2 INR1 52044-1545 R2567 INL14/SLIN2 AGND5 R3019 SOUND 2125 INR15/SWIN2 SUB1L XMICDET R3020 R2740 R2741 INL15/CIN2 SUB1R V-7_A...
Page 88 SC-68...
Page 89 SC-68...
Page 90 SC-68...
Page 91 SC-68...
Page 92: Audio Assy (2/3)
GNDA pattern A *R6706 awx1124 22u/50 awx1274 R3095 awx1275 R6701 PRE_BUF R3096 V-12_A ZONE2<-> awx1122 R6702 ZONE3 OUT awx1123 pattern A R3097 awx1124 awx1119 awx1120 awx1274 R3098 GNDA awx1121 awx1275 R6797 R3099 R6798 R3100 R6799 R6800 R6706 GNDA GNDA SC-68...
Page 93 AUDIO ASSY (2/3) PRE_BUF(B-9 I-9) awx1119 (SC-68 : AWX1119) awx1120 awx1121 JACK awx1122 awx1123 awx1124 (SC-67 : AWX1122) awx1274 awx1275 awx1122 awx1123 awx1119 R3109 awx1124 awx1120 awx1121 R3110 awx1275 awx1274 R3160 JA3101 AKB7246-A AKB7242-A JA3102 AKB7248-A AKB7250-A R3209 R3210 JA3201...
Page 94: Audio Assy (3/3)
C2758 R2670 390k 390k R2671 R2672 mark found on some component parts should be replaced R2673 R2674 with same parts (safety regulation authorized) of identical PHONO(p1 J-3) designation. awx1120 awx1121 awx1123 awx1124 awx1119 awx1274 awx1122 awx1275 IC2661 NJM4565MD UPC4570G2-A SC-68...
Page 95 AUDIO ASSY (3/3) awx1120 (SC-68 : AWX1119) awx1123 awx1119 awx1274 awx1122 awx1275 (SC-67 : AWX1122) 27p/50 100u/50 100u/50 100u/50 100u/50 0.01u/50 0.01u/50 10p/50 330p/50 330p/50 10p/50 10p/50 10p/50 10p/50 100p/50 100p/50 10p/50 10p/50 10p/50 10p/50 10p/50 0.1u/50 0.1u/50 2.2k 2.2k 3.3k...
Page 96: Dac High Assy (1/2)
CCG1222-A 39k(1/8W) Ratings: Capacity(F)/Voltage(V) unless otherwise noted. AWX1254- YB:CKSRYB, QYB:CKSQYB, SYB:CKSSYB, CH:CCSRCH, SCH:CCSSCH AT:CEAT, ZL:CEHAZL, QHX:CFHXSQ 3. NM: No Mount CN3783 mark found on some component parts should be replaced with same parts (safety regulation authorized) of identical designation. SC-68...
Page 97 DAC HIGH ASSY (1/2) (SC-68 : AWX1104) (SC-67 : AWX1109) V+3R3_D A/D GATE R2088 R2084 V+3R3_D2 R2380 L2007 R2381 QTL1013-A AWX1104- AWX1109- AWX1253- AWX1254- R2085 ADMCLK *R2088 IC2010 (1/4) TC74VHC08FK R2354 R2086 ADLRCK *R2380 IC2010 (2/4) R2355 TC74VHC08FK R2087 ADBCK...
Page 98: Dac High Assy (2/2)
VREFHL GNDDAS 3216 A_ADAFHROUT 2.2k C2232 VREFLR VREFLL 2.2k *C2247 R2338 10u/50 330p/50 AK4480EF RNB4580F R2333 R2334 C2248 C2223 C2233 3216 100p/50 C2222 330p/50 2.2k 2.2k C2224 V-12_A GNDDA 0.01u/50 C2234 3216 330p/50 0.1u/50 R2335 R2336 GNDD R2320 1.8k SC-68...
Page 99 DAC HIGH ASSY (2/2) (SC-68 : AWX1104) DAC/ADC (SC-67 : AWX1109) A_ADAFLOUT A_ADAFROUT NOTE Unit: k-k , M-M unless otherwise noted. Rated Power: 1/16w or NETWORKS-1/32w unless otherwise noted. Toleranee: (J)5% unless otherwise noted. 2. CAPACITORS Unit: p-pF or u-uF unless otherwise noted.
Page 100: Front Hdmi Usb Assy
Rated Power: 1/16w unless otherwise noted. designation. Toleranee: (J)5% unless otherwise noted. 2. CAPACITORS No marked Capacitors are CEAT or CKSRYB or CKSSYB. CH: CCSRCH or CCSSCH Unit: p-pF or u-uF unless otherwise noted. Ratings: Capacity(F)/Voltage(V) unless otherwise noted. 3. NM: No Mount SC-68...
Page 101 CEC_IO *R8059 Q8012 R8079 D8007 R8052 GNDCH JP8001 GNDCH R8080 ADX7760-A V+UN_USB R8053 V+UN_USB GNDG CN3652 R8054 V+5_EV Q8004 2SC4154-11(EF) L8001 ATL7010-A V+5_USB_DC L8002 ATL7010-A L8003 C8038 CTH1446-A 0.1u/50 CN8001 AKM1277-A GNDD XUSBERR 10/11 USBPOW GNDD CN9202 (Except MID/CU) SC-68...
Page 102: Usb Rect Assy And Multi Ch In Assy (Sc-68)
10.7 USB RECT ASSY and MULTI CH IN ASSY (SC-68) USB RECT ASSY (AWX1118) ANH7250-A IBZ30P080FCC FU10 V+UN_USB H3652 H3651 AKR1004-A AKR1004-A D3651 *CN3651 D5SBA60(B) C3657 B3B-EH CN3652 S7-1 B2B-EH V+UN_USB S7-2 GNDUSB JP8001 C3655 C3656 GNDUSB KN3651 AKF7002-A AEF7008-A...
Page 103 MULTI CH IN ASSY (SC-68 : AWX1184) C7766 R7764 DUMMY JA7761 22u/50 DKB1083-A C7765 R7763 22u/50 GNDA C7778 DUMMY R7776 FR IN JA7761 22u/50 GNDA FL IN GNDA SW IN GNDA DKB1083-A C7777 R7775 C IN 22u/50 GNDA CN7672 C7772...
Page 104: Usb Dac Assy (Sc-68)
10.8 USB DAC ASSY (SC-68) CN5502 V+3R3_USBSW GNDD V+3R3_USB GNDD GNDD RTQ040P02 Q5622 GNDD GNDD Q5621 R5625 2SC4154-11(EF) GNDD V+3R3_USB R5621 R5623 C5623 0.1u/16 Q5700 GNDD GNDD R5704 R5705 Q5701 V+3R3_USBSW L5521 VTL1129-A L5501 *L5509 BTX1040-A GNDD R5706 VCH1234-A MVG6.3VC220MF60TP...
Page 105 USB DAC ASSY (SC-68 : AWX1097) GNDD Q5506 HN1K02FU GNDD R5648 TP5508 TP5509 TP5510 XGPIO_3 TP5511 XGPIO_2 XPEE_D7 XPEE_D7 EE_A12 XPEE_A10 XPEE_D6 XPEE_A11 EE_A13 XPEE_D6 XPEE_D5 EE_A14 XPEE_D5 XPEE_D4 EE_A15 XPEE_D4 R5631 XPEE_D3 EE_CEN XPEE_D3 XPEE_D2 EE_WRN XPEE_D2 XPEE_D1 EE_RDN...
Page 106: Digital Main Assy (1/11)
470p/50 RADD18 EMDQ3 RADD17 EMDQ2 GND_22 RADD16 V+3R3_HHH EMDQ1 GND_23 VDD3_5 EMDQ0 C201 C198 0.01u/25 VDD2_6 C149 330p/50 C184 0.1u/16 C185 330p/50 IC104 TC7WHU04FK R224 CLK27EM R223 GNDD V+3R3_EM X101 GND1 GND2 ASS7123-A 27.0MHz D101 Q101 GNDD 1/11 GNDD SC-68...
Page 107 DIGITAL MAIN ASSY (1/11) 1/11 (SC-68 : AWX9904) (SC-67 : AWX1198) V+3R3_EM CN101 EMMA_GUI 4/11 JTMRST R170 TRST HDATA14 R171 EJSNGEN JTDI R172 V+3R3_EM JTDO R173 HDATA15 R174 R200 DINTEN V+3R3_EM JTMS R175 EJTAG JTCL R176 JTRST R177 HDATA13 R178...
Page 108: Digital Main Assy (2/11)
10.10 DIGITAL MAIN ASSY (2/11) DIGITAL MAIN ASSY (2/11) V+5_ 2/11 (SC-68 : AWX9904) (SC-67 : AWX1198) TC74VHCT126AFK IC611 (1/4) NW232RX 10/11 C662 0.1u/16 1/11, 3/11 - 9/11 C659 100p/50 CONT_EMMA CONT_GA XMICDET 3/11 - 11/11 BTRX2 R693 C629 BTPOW...
Page 109 GND3 RYFW GNDD GND2 GNDD GND4 Rear Side GNDD GNDD CN7802 REAR PANEL KN602 GND1 GND3 GND2 GND4 VNE1948-A mark found on some component parts should be replaced with same parts (safety regulation authorized) of identical GNDD 2/11 designation. SC-68...
Page 110: Digital Main Assy (3/11)
Data0- 130k Data0 Shield R7X0+ GND2 Data0+ R7X1- 6/11 Data1- GND1 Data1 Shield R7X1+ X9601 Data1+ ASS7123-A 27MHz R7X2- HDMI ZONE Data2- GNDD V+1R3_PP Data2 Shield V+3R3_HHH R7X2+ L9614 L9617 Data2+ VTL1129-A VTL1129-A GNDD CEC_IO_1 GNDD GNDD 6/11 3/11 SC-68...
Page 111 DIGITAL MAIN ASSY (3/11) 3/11 JA8003 JA9605 (SC-68 : AWX9904) AKP7268-A HDMI IN 5 (SC-67 : AWX1198) MHLDET R9154 HPD_3 GNDD SDA_3 V+5_EV R9635 SCL_3 L9608 JA9606 MHL_CTL V+5_F 2/11 L9609 AKP7268-A MHL_CTL R9636 R3XC- V+5_R5 V+5_F GNDD R3XC+ R9654...
Page 112: Digital Main Assy (4/11)
R3PWR5V R7X1+ R3X1+ DSDA2 R7X2- DSCL2 R7X2+ C924 R995 C970 100p/50 C925 0.1u/16 V+1R2_HD L903 V+3R3_HHH VTL1129-A L904 VTL1129-A C971 GNDD V+5_HD R958 GNDD V+3R3_HHH C910 GND2 R939 2.2k GNDD GND1 Q901 SSM3K15FU X901 ASS7123-A 27MHz R940 GNDD 4/11 SC-68...
Page 113 DIGITAL MAIN ASSY (4/11) 4/11 (SC-68 : AWX9904) (SC-67 : AWX1198) V+3R3_HHH C929 L909 R909 R907 C930 IC904 R941 GNDD GNDD NWJPG EMMA_GUI GNDD 1/11 R942 RXOCLK 10/11 DV_RX V+3R3_HHH 5/11 V+3R3_HHH V+3R3_HHH V+3R3_HHH R911 R910 R923 V+3R3_HHH L905 ATL7010-A...
Page 114: Digital Main Assy (5/11)
MV_DQ3 R1323 MV_DQSB0 MV_DQS0 R1324 MV_DQ4 R1243 MV_DQ5 MV_DQ6 MV_DQ7 MV_CSZ MV_CKE R1304 MV_ADR0 V+3R3_M MV_ADR1 R1241 R1247 MV_ADR2 4.7k MV_ADR3 V+1R8_MV_PLA VTL112 IC1204 88DE2750 R1237 GNDD GNDD R1335 X1201 V+1R8_SC GND2 R1219 GND1 ASS7114-A 20MHz R1220 GNDD 5/11 SC-68...
Page 115 DIGITAL MAIN ASSY (5/11) 5/11 (SC-68 : AWX9904) (SC-67 : AWX1198) mark found on some component parts should be replaced with same parts (safety regulation authorized) of identical V+3R3_MV designation. All 1u/10 is DCH1246-A. GNDD DV_Tx 6/11 V+REF_MV_DDR V+3R3_MV V+3R3_HHH...
Page 116: Digital Main Assy (6/11)
R1726 5.1k C1619 1u/10 C1620 V+3R3_HHH L1629 VTL1129-A 3/11, 4/11, 7/11 - 9/11 V+5_HD GNDD V+3R3_HHH C1645 0.1u/16 L1636 VTL1129-A C1647 330p/50 IC1613 P1_SPDIF/DSDSL V+1R3_PP R1782 7/11 HDSPDIFRX R1783 VTL1 DSPI2S RX_SPDIF/DSDSL R1741 7/11 R1742 R1784 TC74VHCT126AFK GNDD 6/11 SC-68...
Page 117 DIGITAL MAIN ASSY (6/11) 6/11 (SC-68 : AWX9904) mark found on some component parts should be replaced with same parts(safety regulation authorized) of identical (SC-67 : AWX1198) designation. HDMI OUT MAIN (OUT1) JA1601 AKP7268-A L1609 ATH7064-A Data2+ PP2T0X2+ PP2T0X2- Data2 Shield...
Page 118: Digital Main Assy (7/11)
(1608) IC1806 ASS7101-A CTF1379-A (3/4) DAZDB NZ2520SD 22.5792MHz (NDK) L1805 ZDBIMCLK IC1803 ICS87002BM-05 CONT_GA IC1806 R1804 (2/4) ICLK R1809 R1832 VDD1 CLK1 FMCLK R1801 GND1 VDD2 CLK2 GND2 IC1806 8/11 (4/4) 7/11 2/11 - 6/11, 8/11 - 11/11 GNDD SC-68...
Page 119 DIGITAL MAIN ASSY (7/11) 7/11 (SC-68 : AWX9904) V+3R3_DSP (SC-67 : AWX1198) V+3R3_DSP C1544 C1535 V+3R3_DSP GNDD MASTER CLOCK SELECTOR C1540 C1551 L1503 0.1u/16 VTL1129-A IC1510 C1552 R1582 SELCTOR 330p/50 R1583 A Network B USBB DIRMCK L1815 C1854 0.1u/16 DIRMCKO...
Page 120: Digital Main Assy (8/11)
AHCLKR0/GP2(14)/BOOT(11) AXR1(10)/GP5(10) 100p/50 7/11 ACLKR0/ECAP1/APWM1/GP2(15) UART0_TXD/I2C0_SCL/TM64P0_OUT12/GP5(9)/BOOT(9) AFSR0/GP3(12) UART0_RXD/I2C0_SDA/TM64P0_IN12/GP5(8)/BOOT(8) AMUTE1/EPWMTZ/GP4(14) AXR1(0)/GP4(0) FMCLK R9040 V+3R3_DSP CN9001 EMU1 V+1R2_D1 L9004 EMU0 VTL1128-A DSPTCK DSPTCK_RTN L9010 TCK_RET VTL1128-A D2TDO C9001 (1608) 0.1u/50 GNDD V+3R3_D C9078 DSPTDI DSPXTRST /TRST DSPTMS GNDD DSP_JTAG 9/11 8/11 SC-68...
Page 121 DIGITAL MAIN ASSY (8/11) 8/11 (SC-68 : AWX9904) (SC-67 : AWX1198) V+3R3_D1 C9010 0.01u/25 64M SDRAM C9011 IC9001 M12L64164A-5TG2M-K 100p/50 VDD1 VSS3 R9011 R9018 DQ15 C9012 D1DQ0 D1DQ15 VDDQ1 VSSQ4 0.1u/16 D1DQ1 D1DQ14 DQ14 D1DQ2 D1DQ13 DQ13 C9013 C9025 D1DQ3...
Page 122: Digital Main Assy (9/11)
XDSP2EN R9738 ACLKX0/ECAP0/APWM0/GP2(12) SPI1_ENA/UART2_RXD/GP5(12) C9119 D2LRCK R9737 AFSX0/GP2(13)/BOOT(10) AXR1(11)/GP5(11) 0.1u/16 C9760 DVDD18 DVDD1 0.1u/16 C9750 AHCLKR0/GP2(14)/BOOT(11) AXR1(10)/GP5(10) 100p/50 ACLKR0/ECAP1/APWM1/GP2(15) UART0_TXD/I2C0_SCL/TM64P0_OUT12/GP5(9)/BOOT(9) AFSR0/GP3(12) UART0_RXD/I2C0_SDA/TM64P0_IN12/GP5(8)/BOOT(8) AMUTE1/EPWMTZ/GP4(14) XDSP2IRQ AXR1(0)/GP4(0) PQMCLK R9754 R9740 7/11 V+1R2_D2 L9703 VTL1128-A GNDD L9705 VTL1128-A 8/11 8/11 DSP_JTAG 9/11 SC-68...
Page 123 V+3R3_D2 DIGITAL MAIN ASSY (9/11) C9708 9/11 0.01u/25 64M SDRAM (SC-68 : AWX9904) C9709 IC9701 M12L64164A-5TG2M-K 100p/50 (SC-67 : AWX1198) VDD1 VSS3 R9726 DQ15 C9710 D2DQ15 VDDQ1 VSSQ4 0.1u/16 D2DQ14 DQ14 D2DQ13 DQ13 C9711 C9723 330p/50 D2DQ12 VSSQ1 VDDQ4 0.1u/16...
Page 124: Digital Main Assy (10/11)
*C9239 *C9236 GNDD R9340 *C9233 DCH1201-A DCH1201-A GNDD DCH1201-A (2125) (2125) (2125) R9341 XUSBERR L9217 CN8001 USBPOW V+1R2_NW V+3R3_NWVDD C9307 C9306 GNDD GNDD GNDD R9359 GNDD R9345 R9349 X9201 GND2 R9346 GND1 NWJPG DSS1203-A 24MHz GNDD GNDD GNDD 10/11 SC-68...
Page 125 DIGITAL MAIN ASSY (10/11) 10/11 mark found on some component parts should be replaced (SC-68 : AWX9904) with same parts(safety regulation authorized) of identical designation. (SC-67 : AWX1198) V+3R3_NWVDD IC9205 TC58NVG0S3ETA00-K V+3R3_NWVDD NC48 C9203 NC47 0.1u/16 NC46 C9204 NC45 IC9201...
Page 126: Digital Main Assy (11/11)
GNDD GNDD GNDD R9480 GNDD V+1R3_PP V+3R3_NW V+3R3_OS V+5_F V+5R6_DDD V+5R6_DDD GNDD R9486 IC9524 1608 C1965 0.1u/50 GNDD GNDD GNDD GNDD COMP GNDD V+1R8_HHH V+1R5_EM V+3R3_EM L9533 L9406 ATH7092-A ATL7010-A (2125) BD9328EFJ R9483 (2125) GNDD GNDD GNDD GNDD 11/11 SC-68...
Page 127 DIGITAL MAIN ASSY (11/11) 11/11 (SC-68 : AWX9904) V+3R3_EM (SC-67 : AWX1198) RTQ040P02 Q9507 R9439 mark found on some component parts should be replaced 2ndDSP POWER BLOCK with same parts(safety regulation authorized) of identical C430 All 1u/10 is DCH1246-A. designation.
Page 128: Interface Assy
CH : CCSRCH , CFTLA : CFTLA JA7003 NO MARKED : CKSRYB or CEAK 3. NM: No Mount 12V TRG1 Q7003 RT1N241M 12V TRG2 mark found on some component parts should be replaced with same parts(safety regulation authorized) of identical AKN-209-A 12VTRG2 designation. GNDV SC-68...
Page 129 GNDD JV7001 Q7024 R7085 2SC4154-11(EF) Q7023 2SC4154-11(EF) GNDD GNDD GNDV GNDD GNDV GNDF GNDV GNDV GNDD R7088 Near AMP and 12V TRG KN7006 AKF7002-A 12V TRG1 12V TRG2 : Video Signal Route -209-A : Audio Signal Route GNDV GNDD SC-68...
Page 130: Component Assy (1/2)
Unit: p-pF or u-uF unless otherwise noted. *R8634 Ratings: Capacity(F)/Voltage(V) unless otherwise noted. *C8616 AK : CEAK 1000p or less : CCSRCH, Over 10u and 2125 : CKSQYB *R8631 NO MARKED : CKSRYB 3. NM: No Mount GNDCH232 GNDD GNDV SC-68...
Page 131 COMPONENT ASSY (1/2) (SC-68 : AWX1106) (SC-67 : AWX1107) V+5R6_EV GNDD R8502 V+5_V [Max +15mA] V+5_OS1 R8503 5.1k A_CVIN_OSD 232C V+5_V V+5_OS1 V+5_OS2 V-5_V *R8520 R8512 GNDV *R8521 [Max +20mA] R8504 L8501 X8501 R8505 OSDSCK_5 V+3_V R8506 OSDCS_5 GNDV GNDV...
Page 132: Component Assy (2/2)
10.22 COMPONENT ASSY (2/2) SC-68...
Page 133 COMPONENT ASSY (2/2) (SC-68 : AWX1106) (SC-67 : AWX1107) SC-68...
Page 134: Composite Assy
Rated Power: 1/10w unless otherwise noted. Toleranee: (J)5% unless otherwise noted. 2. CAPACITORS Unit: p-pF or u-uF unless otherwise noted. Ratings: Capacity(F)/Voltage(V) unless otherwise noted. CH : CCSRCH : Video Signal Route NO MARKED : CKSRYB 3. NM: No Mount SC-68...
Page 135 COMPOSITE ASSY (SC-68 : AWX1125) (SC-67 : AWX1126) V+5_V AWX1126 AWX1125 AWX1318 AWX1317 JA3601 JA3602 AKB7229-A AKB7230-A JA3603 *JA3601 R3601 Q3602 GNDV AKB7230-A HN1C01FU(YGR) R3603 R3606 R3607 MONITOR Q3601 ISA1602AM1(EF) Q3602 HN1C01FU(YGR) R3633 GNDV R3604 GNDV R3637 GNDV R3641 V-5_V...
Page 136: Mic Hp Assy
GNDCH1 C3490 330p/50 V+7_A R3451 Q3451 R3456 R3498 RT1N241M JA3476 R3457 R3460 (HPL) INC2002AC1 Q3452 6.8k 6.8k HEADPHONE Q3453 INC2002AC1 (HPR) XKB3066-A Q3455 INC2002AC1 R3461 Q3454 INC2002AC1 R3458 6.8k 6.8k R3499 R3459 GNDHP1 JV3473 JV3474 KN3472 GNDCH2 GNDCH1 AKF7002-A SC-68...
Page 137 : Audio Signal Route NOTE 1.RESISTORS Unit: k-k , M-M unless otherwise noted. Rated power: 1/10W unless otherwise noted. Tolerance: (J) 5% unless otherwise noted. 2.CAPACITORS Unit: p-pF, or F unless otherwise noted. Ratings: Capacity( F)/Voltage(V) unless otherwise noted. GNDHP1 SC-68...
Page 138: Display Assy (1/2)
51048-0300 (STD.SURR) R3019 S3005 JOGA JOG_A ASG7029-A C3346 JOGB JOG_B TUNER EDIT GNDD (HOME THX/STEREO) CHEMICON2 BOTTOM SOUND GNDD GNDD CN3501 mark found on some component parts should be replaced with same parts (safety regulation authorized) of identical designation. SC-68...
Page 139 Rated:power :1/10W unless otherwise noted. Tolerance :(J) 5% unless otherwise noted. 2,CAPACITORS Unit :p-pF or F or unless otherwise noted. Ratings :Capacity( F)/Voltage(V) unless otherwise noted. YB :CKSRYB CH :CCSRCH AT :CEAT JQ :CEJQ 3,NM :No mount SC-68...
Page 140: Display Assy (2/2)
10.26 DISPLAY ASSY (2/2) SC-68...
Page 141 DISPLAY ASSY (2/2) (AWX1133) SC-68...
Page 142: Vol Assy And Power Sw Assy
Rated Power: 1/16w unless POWLED RT1N431M otherwise noted. Toleranee: (J)5% unless POWERKEY JH3002 otherwise noted. S3401 2. CAPACITORS GNDD Unit: p-pF or u-uF unless VSG1024-A otherwise noted. Ratings: Capacity(F)/Voltage(V) otherwise noted. GNDD YB : CKSRYB CH : CCSRCE 3. NM: No Mount SC-68...
Page 143: Encoder Assy
1.RESISTORS Unit :k-k , M-M unless otherwise noted. Rated:power :1/10W unless otherwise noted. Tolerance :(J) 5% unless otherwise noted. 2,CAPACITORS Unit :p-pF or F or unless otherwise noted. Ratings :Capacity( F)/Voltage(V) unless otherwise noted. YB :CKSRYB 3,NM :No mount SC-68...
Page 144: Ir Interface_M Assy And Buffer Gnd Assy
CN6803 V-12FL CN3870 V+12C KP200IB5L V+12FL GNDFL V-12C V+12C GNDC V-12C CN4700 V-12FR V+12FR GNDFR CN3880 V+12FL KP200IB5L V-12FL V+12FL CN3802 V-12FL GNDFL AKN7073-A GNDFR CN4100 GNDFL CN3890 AKN7155-A V+12FR GNDFR CN4200 V+12FR V-12FR V-12FR : Audio Signal Route SC-68...
Page 145 Ratings: Capacity(F)/Voltage(V) unless otherwise noted. YB:CKSRYB,CH:CCSRCH 3. NM: No Mount 1608 SIZE 2125 SIZE 3216 SIZE 4700 RS1/16S*** 2125 RS1/10S*** 3216 RS1/8S*** RN1/16S*** 2125 RS1/8SQ*** 3216 RS1/4SA*** 1/8W 1/4W CCSR*** CCSQ*** CCS*** 2125 3216 CKSR*** CKSQ*** CKS*** 4100 4200 SC-68...
Page 146: Ir Buffer Assy
GNDCH1 GNDFR R6853 IC6841(2/2) GNDCH1 UPC4570G2-A R6851 R6854 R6843 1608 SIZE 2125 SIZE 3216 SIZE R6847 RS1/16S*** RS1/10S*** RS1/8S*** 2125 3216 RN1/16S*** RS1/8SQ*** RS1/4SA*** 2125 3216 C6844 1/8W 1/4W CCSR*** CCSQ*** CCS*** CKSR*** *R6848 2125 3216 CKSQ*** CKS*** V-12FR SC-68...
Page 147 IC6821(2/2) Toleranee: (J)5% unless otherwise noted. GNDCH1 UPC4570G2-A R6831 2. CAPACITORS R6834 R6823 Unit: p-pF or u-uF unless otherwise noted. R6833 Ratings: Capacity(F)/Voltage(V) unless otherwise noted. R6827 YB:CKSRYB,CH:CCSRCH 3. NM: No Mount C6824 *R6828 : Audio Signal Route V-12FL SC-68...
Page 148: D Amp Assy (1/7)
GND_TP DCdetRY D4021 V+5V_S GND_DC DC DETECT RKZ18KG(B Q4020 Q4014 ISA1602AM1(EF) C4051 33 CIRCUIT DC_DETECT1 HN1C01FU(YGR) GND_DC V-64V GND_DC Q4021 2SC4154-11(EF) R5085 R5087 Q4016 R5086 R5088 DC_DETECT2 GND_DC R4017 GNDP R5166 R5165 HN1C01FU(YGR) GND_DC GNDS GND_TP GNDS GND_DC GND_DC SC-68...
Page 149 5V_S D AMP ASSY (1/7) IC4004 TC74VHC08FK-TBB (SC-68 : AWX1214) AMPOVERLOAD D4011 R4088 R4089 Q4015 2/7 - 6/7 (SC-67 : AWX1218) 2SC4154-11(EF) 1SS301 IC4004 IC4004 D4012 1SS301 IC4004 R4016 R4073 Q4012 V+5V_S IC4905 HN1A01FU(YGR) R5067 1SS355 R4065 D4016 TC7SET08FUS1-TLB R4067...
Page 150: D Amp Assy (2/7)
0.22 RS1/8SQ*** RS1/4SA*** V-12V 2125 3216 Unit: p-pF or u-uF unless otherwise noted. 1/8W 1/4W ACN7094-A Ratings: Capacity(F)/Voltage(V) unless otherwise noted. V-64V CCSR*** CCSQ*** CCS*** YB:CKSRYB, QYB:CKSQYB,SYB:CKSYB, CH:CCSRCH CKSR*** 2125 3216 CKSQ*** CKS*** HAT:CEHAT, ZL:CEHAZL 3. NM: No Mount SC-68...
Page 151 D AMP ASSY (2/7) (SC-68 : AWX1214) (SC-67 : AWX1218) ATOR & MOS FET Driver Output Power Stage and LP Filter R4289 KN4100 R4286 D4217 2125 GND1 GND3 RF071M2S 0.47 V+64V Q4201 GND2 GND4 IRF6775MPBF-TRB IC4201 R4237 GATE DRAIN1 VNE1948-A...
Page 152: D Amp Assy (3/7)
3216 2. CAPACITORS RN1/16S*** RS1/8SQ*** RS1/4SA*** 2125 3216 Unit: p-pF or u-uF unless otherwise noted. 1/8W 1/4W Ratings: Capacity(F)/Voltage(V) unless otherwise noted. CCSR*** CCSQ*** CCS*** YB:CKSRYB, QYB:CKSQYB,SYB:CKSYB, CH:CCSRCH CKSR*** 2125 3216 CKSQ*** CKS*** HAT:CEHAT, ZL:CEHAZL 3. NM: No Mount SC-68...
Page 153 D AMP ASSY (3/7) ODULATOR & MOS FET Driver (SC-68 : AWX1214) (SC-67 : AWX1218) Output Power Stage and LP Filter R4489 KN4200 R4486 D4417 2125 GND1 GND3 Q4405 RF071M2S 2SC4154-11(EF) 0.47 V+64V Q4401 GND2 GND4 IRF6775MPBF-TRB IC4401 R4437 GATE...
Page 154: D Amp Assy (4/7)
1/7 - 3/7, 1/7 - 3/7, 5/7, 6/7 5/7, 6/7 GND_TP GNDP GND_TP GND_TP (RTN5) KN4500 *IC4604 VNE1948-A NJM12904V Q4510 Q4511 R4566 2SA1514K(RS) GND1 GND3 GND_TP ISA1602AM1(EF)-TLB R4570 R4567 1k 1% *R4580 Q4508 GND2 GND4 2SC4154-11(EF) GNDP GND_TP GND_TP SC-68...
Page 155 D AMP ASSY (4/7) (SC-68 : AWX1214) (SC-67 : AWX1218) Output Power Stage and LP Filter OS FET Driver R4689 KN4300 R4686 D4617 GND1 GND3 2125 RF071M2S 0.47 V+64V Q4601 GND2 GND4 IRF6775MPBF-TRB IC4601 R4637 GATE DRAIN1 VNE1948-A IRS20957SPBFS1 3216...
Page 156: D Amp Assy (5/7)
V+5V R4709 1/7 - 3/7 C4702 R4764 AMUTE V+5V_S V+64V *IC4704 Q4708 *R4775 NJM12904V 2SC4154-11(EF) Q4710 R4766 R4767 2SA1514K(RS) R4725 0.22 TEMP R4770 ACN7094-A 1/7 - 4/7, 6/7 GND_TP GND_TP GND_TP GNDP *IC4704 R4726 NJM12904V 0.22 ACN7094-A GND_TP V-64V SC-68...
Page 157 D AMP ASSY (5/7) (SC-68 : AWX1214) (SC-67 : AWX1218) Driver Output Power Stage and LP Filter KN4400 R4786 D4717 GND1 GND3 2125 RF071M2S 0.47 Q4701 V+64V GND2 GND4 IRF6775MPBF-TRB IC4701 R4737 GATE DRAIN1 VNE1948-A IRS20957SPBFS1 3216 DRIVER DRAIN2 ACN7194-A...
Page 158: D Amp Assy (6/7)
TEMP_OUT *R4880 1/7 - 5/7 *IC4804 GNDP NJM12904V 1/7 - 5/7 R4909 R4826 R4926 GND_TP 0.22 0.22 GND_TP GND_TP ACN7094-A ACN7094-A *IC4804 NJM12904V Q4911 Q4910 R4966 ISA1602AM1(EF) 2SA1514K(RS) GND_TP V-64V R4970 R4967 Q4908 1k 1% *R4980 2SC4154-11(EF) GND_TP GND_TP SC-68...
Page 159 D AMP ASSY (6/7) TOR & MOS FET Driver (SC-68 : AWX1214) (SC-67 : AWX1218) Output Power Stage and LP Filter R4889 KN4900 R4886 D4817 2125 GND1 GND3 RF071M2S 0.47 V+64V Q4801 GND2 GND4 IRF6775MPBF-TRB IC4801 R4837 GATE DRAIN1 VNE1948-A...
Page 160: D Amp Assy (7/7)
10.37 D AMP ASSY (7/7) SC-68...
Page 161 D AMP ASSY (7/7) (SC-68 : AWX1214) (SC-67 : AWX1218) SC-68...
Page 162: Primary Assy
CAUTION - FOR CONTINUED PROTECTION AGAINST RISK OF FIRE, REPLACE WITH SAME TYPE AND SAME RATING OF FUSE. JV71 JUMPER *S81 JV87 *CN81 B2P3-VH JUMPER_JV 2VOL-SW *JV81 MAIN JUMPER TRANS INC2002AC1 *JV82 JUMPER *JV83 JUMPER JV84 *CN82 JV85 JV86 MAIN TRANS G_CHASSIS1 G_CHASSIS1 SC-68...
Page 163 MUF : RD1/4MUF 2. CAPACITORS Unit: p-pF or u-uF unless otherwise noted. Ratings: Capacity(F)/Voltage(V) unless otherwise noted. CH : CCSRCH , CFTLA : CFTLA AK : CEAK NO MARKED : CKSRYB or CEAT 3. NM: No Mount SC-68...
Page 164: Primary Shield Assy (Sc-67) And Reg Assy
NP : CEANP AK : CEAK with same parts(safety regulation authorized) of identical CAUTION - FOR CONTINUED PROTECTION AGAINST RISK OF FIRE, NO MARKED : CKSRYB or CEAT designation. 3. NM: No Mount REPLACE WITH SAME TYPE AND RATINGS OF FUSE. SC-68...
Page 165 V+5_V IC7601 JP8402 NJM78M05FA CN7603 KM200NA4 V+5_V GNDV GNDV V-5_V GND_V C7630 IC7602 NJM79M05FA V-5_V -10V C7631 KN7601 V+5_V GNDV GNDV D7626 Power Supply for V+12TRG FL DISPLAY FLAC2 FLAC1 -15V CN7602 KM200NA7 JP7725 R7622 54-400 R7623 -23.5V -15V SC-68...
Page 166: Ir Reg Assy
Q7207 RT1N241M Q7212 D7204 2SB1569A D7212 -13.5V *R7277 FU13 +20V IC7251 NJM78M12FA H7252 H7251 D7251 1SR154-400 AKR1004-A-T D7252 1SR154-400 GND_DF D7253 FU14 1SR154-400 D7254 H7254 H7253 AKR1004-A-T 1SR154-400 JH7251 JH7252 JH7253 JH7254 IC7252 AEF7008-A AEF7008-A AEF7008-A -20V NJM79M12FA *R7278 SC-68...
Page 167 -6.5V HIGH +6.5V -6.5V *R7277 V+12_DF IC7251 NJM78M12FA Power Supply for IRPOWER AMP INPUT STAGE & SP RELAY CN7251 KM200NA7 V+12_DF GND_DF GND_DF V-12_DF R7255 R7251 GND_DF(S) R7253 CN4004 V+12_RY V-12_RY R7256 V-12_RY IC7252 R7254 NJM79M12FA GND_DF V-12_DF *R7278 SC-68...
Page 168: B Diode Assy
3216 : RS1/4SA unless otherwise noted. 2. CAPACITORS Unit: p-pF or u-uF unless otherwise noted. Ratings: Capacity(F)/Voltage(V) unless otherwise noted. CFTLA : CFTLA mark found on some component parts should be replaced 3. NM: No Mount with same parts(safety regulation authorized) of identical designation. SC-68...
Page 169: Connect Assy
NOTE 1. RESISTORS Unit: k-k , M-M unless otherwise noted. Rated Power: 1/16w unless otherwise noted. Toleranee: (J)5% unless otherwise noted. 2. CAPACITORS Unit: p-pF or u-uF unless otherwise noted. Ratings: Capacity(F)/Voltage(V) unless otherwise noted. 3. NM: No Mount SC-68...
Page 170: Fb-Connect Assy
NOTE 1. RESISTORS Unit: k-k , M-M unless otherwise noted. Rated Power: 1/16w unless otherwise noted. Toleranee: (J)5% unless otherwise noted. 2. CAPACITORS Unit: p-pF or u-uF unless otherwise noted. Ratings: Capacity(F)/Voltage(V) unless otherwise noted. 3. NM: No Mount SC-68...
Page 171: Pre Bridge Assy
Rated Power: 1/10w unless otherwise noted. Toleranee: (J)5% unless otherwise noted. 2. CAPACITORS Unit: p-pF or u-uF unless otherwise noted. Ratings: Capacity(F)/Voltage(V) unless otherwise noted. CH : CCSRCH NO MARKED : CKSRYB 3. NM: No Mount SC-68...
Page 172: A-Dac Bridge Assy
Rated Power: 1/10w unless otherwise noted. Toleranee: (J)5% unless otherwise noted. 2. CAPACITORS Unit: p-pF or u-uF unless otherwise noted. Ratings: Capacity(F)/Voltage(V) unless otherwise noted. CH : CCSRCH NO MARKED : CKSRYB 3. NM: No Mount SC-68...
Page 173: D-Audio Bridge Assy
Rated Power: 1/10w unless otherwise noted. Toleranee: (J)5% unless otherwise noted. 2. CAPACITORS Unit: p-pF or u-uF unless otherwise noted. Ratings: Capacity(F)/Voltage(V) unless otherwise noted. CH : CCSRCH NO MARKED : CKSRYB 3. NM: No Mount SC-68...
Page 174: D-Dac Bridge Assy
Rated Power: 1/10w unless otherwise noted. Toleranee: (J)5% unless otherwise noted. 2. CAPACITORS Unit: p-pF or u-uF unless otherwise noted. Ratings: Capacity(F)/Voltage(V) unless otherwise noted. CH : CCSRCH NO MARKED : CKSRYB 3. NM: No Mount SC-68...
Page 175: Front Bridge Assy
NOTE 1. RESISTORS Unit: k-k , M-M unless otherwise noted. Rated Power: 1/16w unless otherwise noted. Toleranee: (J)5% unless otherwise noted. 2. CAPACITORS Unit: p-pF or u-uF unless otherwise noted. Ratings: Capacity(F)/Voltage(V) unless otherwise noted. 3. NM: No Mount SC-68...
Page 176: Display Bridge Assy
NOTE 1. RESISTORS Unit: k-k , M-M unless otherwise noted. Rated Power: 1/16w unless otherwise noted. Toleranee: (J)5% unless otherwise noted. 2. CAPACITORS Unit: p-pF or u-uF unless otherwise noted. Ratings: Capacity(F)/Voltage(V) unless otherwise noted. 3. NM: No Mount SC-68...
Page 177: F-In Bridge Assy
NOTE 1. RESISTORS Unit: k-k , M-M unless otherwise noted. Rated Power: 1/16w unless otherwise noted. Toleranee: (J)5% unless otherwise noted. 2. CAPACITORS Unit: p-pF or u-uF unless otherwise noted. Ratings: Capacity(F)/Voltage(V) unless otherwise noted. 3. NM: No Mount SC-68...
Page 178: Mch Bridge Assy (Sc-68)
10.51 MCH BRIDGE ASSY (SC-68) MCH BRIDGE ASSY (SC-68 : AWX1185) CN7671 CN7672 AKM7050-A AKM7050-A GNDA GNDA GNDA GNDA SBL IN SBL IN GNDA GNDA SBR IN SBR IN GNDA GNDA SL IN SL IN GNDA GNDA SR IN SR IN...
Page 179: A Reg Bridge Assy
NOTE 1. RESISTORS Unit: k-k , M-M unless otherwise noted. Rated Power: 1/16w unless otherwise noted. Toleranee: (J)5% unless otherwise noted. 2. CAPACITORS Unit: p-pF or u-uF unless otherwise noted. Ratings: Capacity(F)/Voltage(V) unless otherwise noted. 3. NM: No Mount SC-68...
Page 180: Mic Hp Guard, Fan Connect, Bind Dm Cable And Bind B Cable Assys
(AWX1152) AEF7008-A AEF7008-A JH5924 JH5921 FAN CONNECT ASSY (AWX1197) CN5931 CN5932 V+FAN V-FAN CN7291 LOCKDET AEF7008-A AEF7008-A JH5931 JH5932 BIND DM CABLE ASSY (AWX1189) AEF7008-A JH3551 BIND B CABLE ASSY (AWX1179) AJ AK AL AM AJ AK AL AM SC-68...
Page 181: Ffc Guard, Vreg Guard And Panel Guard Assys
10.54 FFC GUARD, VREG GUARD and PANEL GUARD ASSYS FFC GUARD ASSY (AWX1176) VREG GUARD ASSY (AWX1153) PANEL GUARD ASSY (AWX1154) AN AO AN AO SC-68...
Page 182: Pcb Connection Diagram
C3926 C3275 C3276 C3255 C3256 C3205 C3206 C3105 IC2661 Q3276 Q3275 Q3275 Q3102 Q3271 Q3271 Q3251 Q3101 Q3272 Q6705 Q3251 Q2971 C2663 Q3252 Q6702 Q3201 Q6701 Q3202 R2681 Q3274 Q3151 JA3102 JA3201 JA3101 JA2503 Q3152 JA3202 JA2505 Q3101 Q3102 SC-68...
Page 183 C3902 C6706 C2566 R3093 R6783 R6780 Q3901 C2545 C2525 C2546 C2506 R3091 R6760 C2664 C2663 Q2971 R2682 Q6705 C6734 C6730 R2681 C6729 R6788 R3993 R6787 R3092 JA2503 DVR I R6782 PHONO JA2504 JA2501 VIDEO JA2502 JA3206 DVR O (ANP7825-A) SC-68...
Page 184 TUNER L C3011 R3041 C3013 R3043 R3031 R2544 R2543 R2542 R2541 C2562 R2562 R3009 R3016 R3010 R2561 R2664 C2561 R2662 R2502 R2501 R2666 R2665 R2971 C2971 R2972 C2972 R2522 R2521 R2679 C2986 C2661 C2985 C2501 C2684 C2683 R2959 C2983 SC-68...
Page 185 R3259 R3114 R3113 R3264 R3263 SW OUT R3118 R3117 R3268 R3267 R2602 R2601 R6714 R6720 R2581 R6726 C3946 R3152 R3156 R2664 R2662 R3158 R6713 R3208 R3207 R3258 R3257 R3278 R6712 R6711 R3277 R2666 R2665 C3163 C3113 C2661 C2683 (ANP7825-A) SC-68...
Page 186: Dac High Assy
R2454 C2477 C2176 R2460 R2462 IC2183 IC2181 IC2471 C2460 C2194 IC2106 R2479 C2451 IC2451 IC2451 C2459 C2184 R2493 R2492 C2197 C2178 C2186 R2461 R2459 R2451 C2453 R2453 C2196 C2185 IC2015 CN2104 CN2103 CN2101 CN2104 CN2103 CN2101 CN3791 CN3793 CN3783 SC-68...
Page 187 R2094 [[ G ]] L2471 R2126 A30C5/C7 R2283 C2474 R2195 R2451 R2067 R2064 R2453 R2203 R2128 R2230 R2231 R2125 R2202 R2095 R2238 R2201 R2121 CN2102 CN2101 C2056 R2498 C2174 C2054 C2175 R2239 R2499 R2240 (ANP7824-B) CN2102 CN2101 CN3783 CN3781 SC-68...
Page 188 SIDE B DAC HIGH ASSY C2480 C2489 AWX1 0 1 2 3 0 1 2 3 4 5 6 7 8 9 [[ G ]] A30C5/C7 CN2102 CN2102 SC-68...
Page 189 SIDE B C2446 C2445 R2274 C2321 CN2103 C2320 CN2104 CN2101 CN2103 (ANP7824-B) CN2103 CN2104 CN2101 SC-68...
Page 190: Front Hdmi Usb Assy
Q8001 C8010 IC8002 IC8002 Q8005 C8004 Q8008 MHL_CTL C8002 [[ G ]] Q8006 R8001 2 3 4 A30C5/C7 Q8006 R8005 Q8009 Q8009 D8006 F-HDMI USB ASSY (ANP7827-A) SIDE B SIDE B FRONT HDMI USB ASSY (ANP7827-A) JA8003 JP8001 CN8001 SC-68...
Page 191: Usb Rect Assy
ATTENTION - REMPLACER PAR LE FUSIBLE [[ G ]] PAR UN MODELE IDENTIQUE EN INTENSITE C3658 C3666 C3665 CN3651 R3651 JV3651 1.V+UN_USB 2.GND_USB JH3651 D3651 KN3651 USB RECT ASSY (ANP7836-B) SIDE B SIDE B USB RECT ASSY C3662 C3661 R3653 CN3651 (ANP7836-B) CN3651 SC-68...
Page 192: Multi Ch In Assy (Sc-68)
11.5 MULTI CH IN ASSY (SC-68) SIDE A SIDE A MULTI CH IN ASSY CN5751 CN7762 C7783 KN7761 C7784 J7786 C7771 J7783 C7772 J7782 J7779 C7777 J7778 C7778 J7777 J7764 J7763 C7765 C7766 CN7761 (ANP7836-B) CN7761 CN7672 SIDE B SIDE B...
Page 193 SC-68...
Page 194: Usb Dac Assy (Sc-68)
11.6 USB DAC ASSY (SC-68) SIDE A CN9801 USB DAC ASSY CN5501 Q5621 R5625 Q5622 C5624 C5561 C5625 R5626 R5627 C5503 CN5501 R5509 C5501 R5503 R5706 Q5701 R5701 C5702 C5640 R5695 C5686 Q5506 R5696 R5651 C5566 C5565 C5567 C5617 C5568...
Page 195 C5617 R5644 R5617 R5643 R5618 X5501 C5618 R5632 R5633 C5581 R5531 C5677 R5638 R5637 JA5501 C5564 C5672 C5671 C5563 R5521 L/S=140u/140u R5673 R5674 C5670 R5522 D5670 R5672 R5671 Q5505 R5532 R5530 C5639 R5640 R5641 (ANP7821-A) Q5505 Q5670 IC5512 IC5503 SC-68...
Page 196 SIDE B USB DAC ASSY TP5564 TP5563 TP5510 TP5511 TP5509 TP5508 TP5540 TP5539 rivet SC-68...
Page 197 SIDE B CN5501 TP5564 TP5551 TP5563 rivet [[ G ]] A30C5/C7 (ANP7821-A) SC-68...
Page 198: Digital Main Assy
Q1509 Q1501 Q9508 Q9503 Q9504 Q1503 Q1502 Q1507 Q1506 Q9507 IC612 IC607 IC601 IC608 IC9511 IC613 IC611 IC610 IC1502 IC1504 IC1216 IC9515 IC101 IC104 IC701 IC604 IC911 IC1204 IC603 IC9602 IC910 IC1212 IC9603 IC1813 IC904 IC1506 IC1615 IC903 IC1612 IC160 SC-68...
Page 199 Q9001 Q1602 Q1601 Q1507 Q1506 Q9201 IC1504 IC9102 IC1509 IC1501 IC1809 IC9504 IC9523 IC9518 IC1814 IC1510 IC9522 IC9702 IC603 IC1803 IC9206 IC9514 IC9520 IC9002 IC9524 IC9204 IC9006 IC1506 IC1609 IC9203 IC9521 IC1605 IC9005 IC1612 IC1602 IC1610 IC1808 IC9202 IC9401 SC-68...
Page 200 L9212 L9520 V+1R2_NW L9521 V+3R3_NW C1965 C1901 C1740 V+5_WF V+1R3_PP IC9502 L1618 L1634 V+5_R7 V+5_R4 IC1611 JA9202 Q1603 Q901 IC9510 IC1511 IC1512 IC9701 IC9703 IC9512 IC1508 IC1507 IC1806 IC9508 IC9201 IC1613 IC1802 IC9001 IC9004 IC9205 IC1804 IC9208 IC1614 IC9502 SC-68...
Page 201 0 1 2 3 0 1 2 3 4 5 6 7 8 9 V+5_R3 V+5_R4 V+5_R1 V+5_R2 V+5_R6 L1642 L1617 (ANP7803-B) Q9601 Q601 Q101 Q909 Q910 Q911 Q901 Q906 Q907 Q908 Q9603 Q9602 IC614 IC102 IC9501 IC901 IC902 IC909 IC103 IC9508 SC-68...
Page 202: Interface Assy
C7028 AMP_TEMP D7008 XBERR J7016 J7017 J7011 J7004 J7010 V+12TRG J7003 C7112 J7002 CN7006 JH7002 KN7006 CN7006 CN4000 SIDE B INTERFACE ASSY CN7006 CN7004 CN70 Q7008 Q7015 Q7010 Q7005 Q7021 Q7023 Q7016 Q7003 Q7002 Q7001 Q7022 Q7024 Q7013 Q7014 SC-68...
Page 203 INTERFACE Ass'y XBERR J7012 J7052 J7053 AWX1172 [[ G ]] J7051 V+5_V J7011 J7010 V+12TRG J7050 CN7002 KN7004 CN7007 (ANP7835-A) CN7002 CN7007 CN7681 CN7682 SIDE B CN7002 CN7007 (ANP7835-A) CN7003 JP7001 CN7005 CN7008 Q7026 Q7028 Q7027 Q7025 Q7030 Q7029 SC-68...
Page 204: Component Assy
R8315 R8314 R8606 R8313 R8607 R8312 C8609 R8624 R8614 R8317 R8316 R8321 IC8501 R8343 R8341 R8320 Q8301 R8344 R8342 R8319 C8385 R8318 R8345 Q8301 C8601 C8386 R8346 Q8303 R8347 Q8302 IC8601 R8348 Q8603 Q8605 Q8604 C8610 R8616 R8617 (ANP7826-A) SC-68...
Page 205 C8333 C8336 Q8501 C8330 R8415 Q8401 D8406 R8606 R8503 R8607 C8609 R8624 R8614 C8501 C8522 R8343 R8341 C8384 R8504 Q8301 R8344 R8342 D8301 R8505 C8385 R8506 R8345 C8386 R8346 R8347 L8501 X8501 R8348 R8371 Q8303 R8372 C8388 C8387 (ANP7826-A) SC-68...
Page 206 SIDE B COMPONENT ASSY R8406 R8403 C8405 GNDF C8404 FRONTV C8430 R8402 R8405 R8625 R8414 C8347 R8412 C8342 V-5_V GNDV GNDV V+5_V R8330 R8407 R8409 R8511 R8501 R8510 R8502 C8524 C8502 SC-68...
Page 207 R8307 C8308 C8314 C8367 C8316 C8347 C8320 C8368 C8342 C8323 R8308 C8325 C8344 C8328 C8370 C8372 R8330 C8371 R8501 C8373 R8373 R8502 C8375 C8390 C8374 C8389 C8502 C8608 C8607 C8602 C8619 R8611 R8392 R8618 C8393 R8609 C8394 R8619 (ANP7826-A) SC-68...
Page 208: Composite Assy
R3612 Q3603 R3611 Q3604 [[ G ]] A30C5/C7 C3621 C3622 COMPOSITE ASS'Y R3615 C3608 AWX1116 C3610 Q3606 AWX1125 R3617 R3616 R3621 Q3606 Q3605 R3644 AWX1126 R3619 R3620 C3612 C3613 R3628 R3623 Q3607 R3622 R3627 Q3608 R3643 R3625 R3624 (ANP7825-A) SC-68...
Page 209 SIDE B SIDE B COMPOSITE ASSY C3620 COMPOSITE ASS'Y AWX1116 AWX1125 AWX1126 [[ G ]] A30C5/C7 (ANP7825-A) SC-68...
Page 210: Mic Hp Assy
SIDE A SIDE A MIC HP ASSY 1148 AWX 1149 J3459 CN3472 HP R MICDET J3456 J3458 J3454 V+7_A AMUTE GNDA J3457 C3484 C3483 C3478 JA3476 KN3472 KN3471 MIC HP Ass'y [[ G ]] J3451 (ANP7828-A) GNDCH1 JA3471 C3474 SC-68...
Page 211 MIC HP ASSY AWX1148 1149 V-7_A CN3472 Q3453 Q3455 V+7_A R3455 R3457 R3458 C3461 C3462 Q3452 Q3454 R3499 R3498 C3452 C3451 V-7_A_R C3479 IC3471 C3469 C3468 R3469 R3468 IC3471 (ANP7828-A) C3460 3.MICOUT 1.FRONTV 2.GNDCH1 2.MICOUT C3457 MIC HP Ass'y 1.GNDCH1 SC-68...
Page 212: Display Assy
C3208 V+5_V D3212 J3026 V+5_V J3100 J3035 GNDV J3025 J3009 NO USE J3047 S3017 S3019 V+5_EV_1 S3015 S3014 J3123 S3002 S3009 J3057 J3083 J3122 V+5_EV_1 S3006 J3040 GNDD V+5_EV_1 ¡AWX S3010 S3007 S3012 S3011 JV3000 S3008 S3013 S3018 S3016 SC-68...
Page 213 J3126 GNDD GNDD XBERR J3072 X3001 XDCERR NO USE J3018 XFANERR ¡AWX1131 J3055 ¡AWX1132 J3031 3047 XRESET ¡AWX1205 _EV_1 ¡AWX1208 J3123 S3002 S3001 S3003 S3004 S3005 J3057 J3122 Contact Side ¡AWX1209 GNDD CN3004 ¡AWX1255 ¡AWX1133 ¡AWX1206 (ANP7828-A) CN3004 CN8002 SC-68...
Page 214 R3024 R3106 R3017 R3016 R3058 C3007 R3011 C3004 C3005 C3006 NO USE C3017 R3015 C3043 R3007 R3120 JH3004 R3010 C3045 D3005 D3004 R3002 C3221 R3225 R3134 R3221 C3222 R3223 CN3004 CN3004 Q3004 Q3210 Q3211 Q3204 Q3203 Q3216 IC3003 IC3001 SC-68...
Page 215 R3245 C3204 JH3003 C3306 C3210 R3217 GNDD R3206 C3307 R3205 V+5_V R3204 R3018 GNDV R3202 R3017 R3203 R3016 NO USE 3015 JH3002 C3035 R3083 R3230 R3221 V+5_EV_1 3223 C3345 Q3214 Q3215 (ANP7828-A) Q3205 Q3206 Q3212 Q3213 Q3215 Q3214 IC3201 SC-68...
Page 216: Vol Assy, Power Sw Assy And Encoder Assy
11.13 VOL ASSY, POWER SW ASSY and ENCODER ASSY SIDE A SIDE A VOL ASSY VOL Ass'y S3371 NO CLICK AWX1134 J3371 GNDD CN3371 (ANP7828-A) POWER SW ASSY 1.V+5_EV_1 2.POWLED 3.POWER_KEY 4.GNDD (ANP7828-A) ENCODER ASSY S3501 Click ENCODER Ass'y AWX1150 J3501 CN3501 (ANP7828-A) M N O SC-68...
Page 217 GNDD CN3371 (ANP7828-A) POWER SW ASSY ¡AWX1135 ¡AWX1151 ¡AWX POWER SW Ass'y 1.V+5_EV_1 2.POWLED 3.POWER_KEY 4.GNDD Q3401 CN3401 C3401 V+5_EV [[ G ]] (ANP7828-A) ENCODER ASSY C3501 C3502 [[ G ]] ENCODER Ass'y 1150 CN3501 (ANP7828-A) M N O SC-68...
Page 218: Ir Buffer Assy
R7471 IC7491 C6831 C7461 C6811 IC6841 C7452 C6842 R6885 IC6821 IC6801 C6822 C6802 C7481 C6841 IC7471 R6850 C7472 C7451 C6821 C6801 R6851 C7471 C6850 C6853 C6830 C6810 C7460 R8929 C6833 C6813 C7480 KN6801 IC7491 IC6841 IC6821 IC6801 IC7471 IC7451 SC-68...
Page 219 R6927 C6885 C6924 R6881 C6926 C6930 C6865 C6871 C6892 C6891 C7461 R6861 C6862 IC6861 R8918 IC6881 C7452 R8919 R6885 C6861 R8920 R6870 C6881 R8921 C7451 R6871 R6890 R6891 R8922 C6870 R8923 C6890 R8924 (ANP7834-B) IC6901 IC6921 IC7451 IC6881 IC6861 SC-68...
Page 220 A30C5/C7 R6878 R6857 R6837 R6817 R7488 R7468 R6898 R6938 R6918 R6858 R6917 R6838 R6897 R6877 R6937 R7467 R6818 R7487 R6916 R6904 R6936 R6924 AWX1170 AWX1 0 1 2 3 0 1 2 3 4 5 6 7 8 9 SC-68...
Page 221 SIDE B CN6801 CN6801 (ANP7834-B) SC-68...
Page 222: Buffer Gnd Assy And Ir Interface_M Assy
IR INTERFACE_M AS KN6962 C3820 C3819 C3826 C3824 C3822 C3823 C3821 C3825 KN6961 CN3820 CN3830 CN3840 CN3810 CN3810 CN3820 CN3830 CN3840 (ANP7834-B) CN4900 CN4800 CN4300 CN4400 SIDE B IR INTERFACE_M AS BUFFER GND ASSY CN3810 CN3820 CN3830 CN3840 (ANP7834-B) SC-68...
Page 223 C3835 C3830 C3827 C3832 C3834 C3829 C3831 C3833 CN3890 CN3880 CN3840 CN3870 CN3860 CN3850 CN3840 CN3850 CN3860 CN3870 CN3880 CN3890 CN4400 CN4500 CN4600 CN4700 CN4100 CN4200 SIDE B RFACE_M ASSY CN3840 CN3850 CN3860 CN3870 CN3880 CN3890 CN3801 CN3802 (ANP7833-A) SC-68...
Page 224: D Amp Assy
C4200 AWH7052 AWX1214 C4059 C4058 AWH7053 AWX1215 C4057 AWH7054 AWX1216 C4083 C4084 BOND BOND BOND DATA XOLERR XBERR ICEMUTEA RY4100 RY4700 ICEMUTESB MUTEFH RY FW RY AF RY5000 RY CR RY FH RY B AMPTEMP XTEMPERR5 XDCERR GNDHD GNDHD SC-68...
Page 225 C4400 C4800 AWH7052 AWX1214 AWH7055 AWX1217 C4062 AWH7058 AWX1220 AWH7053 AWX1215 AWH7059 AWX1221 C4061 AWH7056 AWX1218 C4060 AWH7054 AWX1216 AWH7057 AWX1219 AWH AWX [[ G ]] A30C5/C7 C4083 C4084 D-AMP ASS'Y ANP7837-C C4010 BOND C4036 RY4500 RY4300 RY4900 (ANP7837-C) SC-68...
Page 226 SIDE B D AMP ASSY CN4900 CN4500 CN4800 CN4300 CN4400 0 1 2 3 0 1 2 3 4 5 6 7 8 9 SC-68...
Page 227 SIDE B CN4500 CN4200 CN4600 CN4700 CN4100 0 1 2 3 4 5 6 7 8 9 (ANP7837-C) SC-68...
Page 228: Primary Assy And Primary Shield Assy (Sc-67)
11.17 PRIMARY ASSY and PRIMARY SHIELD ASSY (SC-67) SIDE A PRIMARY ASSY PRIM SECONDARY PRIMARY SIDE SIDE KN50 The Parts must not enter this area. BOND PRIMARY SHIELD ASSY [[ G ]] (ANP7835-A) SC-68...
Page 229 SIDE A AC CORD AC CORD MAIN TRANS JA71 JA71_1 CN81 PRIMARY Ass'y CAUTION -REPLACE FUSE LINKS AS MARKED. FU4 215002. MFD.BY LITTELFUSE INC. (ANP7828-A) SC-68...
Page 230 SIDE B PRIMARY ASSY CN81 JA71_1 JA71 AWX1145 AWX1248 AWX1225 AWX1146 PRIMARY Ass'y AWX1226 AWX1147 AWX1136 AWX1137 AWX1138 AWX1139 AWX1142 AWX1140 AWX1143 AWX1141 AWX1144 SC-68...
Page 231 SIDE B IC52 1.V+5R6_EV 2.V+5R6_EV 3.V+5R6_EV 4.GNDD 5.GNDD 6.GNDD 7.RYAC V+5R6_EV (ANP7828-A) IC52 PRIMARY SHIELD ASSY [[ G ]] rivet rivet CN5751 (ANP7835-A) CN5751 SC-68...
Page 232: Reg Assy
RISK OF FIRE - C7623 C7612 REPLACE FUSE 1.V+5_V AS MARKED. 2.GNDV 3.GNDV 4.V-5_V C7602 2200/16 J7605 GNDV REG ASS CN750 IC7602 IC7521 IC7602 IC7601 IC7611 IC7601 IC7501 79M05 78M05 78M12 IC7611 IC7502 SIDE B REG ASSY CN750 CN7601 SC-68...
Page 233 LITTELFUSE INC. FOR P7521 S4-1-2 AND P7522 5.V-12_A 4.GNDA 3.GNDA C7502 2.V+12_A C7511 C7506 FU22 1.V+6_AD C7505 H7504 H7503 C7525 AWX1180 REG ASSY CN7502 C7507 C7508 C7523 IC7502 JP5775 IC7521 79M12 78M06 IC7501 78M12 (ANP7836-B) SIDE B CN7502 (ANP7836-B) N7601 SC-68...
Page 234: Ir Reg Assy And B Diode Assy
IC7251 J7203 FAN_H J7235 GND_MD J7210 CN7251 J7204 GND_MD C7271 C7272 JV7202 2200/16 2200/16 [[ G ]] GND_MD J7227 SEC9-2 JV7204 GND_MD IC7252 2200/25 JH7253 RISK OF FIRE - CN7201 REPLACE FUSE AS MARKED. CN7201 CN7251 MAIN TRANS CN4004 SC-68...
Page 235 C7401 C7400 J7208 JV7402 JV7400 V+12DF CN7401 JV7403 JV7401 H7404 H7400 H7403 H7401 7227 FU61 FU62 SEC9-2 GND_DF J7206 RISK OF FIRE-REPLACE GND_DF FUSE AS MARKED (ANP7835-A) J7205 CN7401 V-12DF_IN CN4001 V-12DF J7207 J7228 2200/25 V-12DF JH7253 (ANP7835-A) 4004 SC-68...
Page 236 SIDE B IR REG ASSY B DIODE ASSY CN7400 CN7400 Q7224 R7403 Q7223 Q7225 Q7226 Q7222 Q7221 C7406 C7407 Q7206 Q7207 Q7205 R7405 R7406 Q7203 Q7204 CN7401 C7410 C7411 R7407 R7408 (ANP7835-A) CN7401 SC-68...
Page 237 CN7271 CN7291 CN7271 CN7281 AWX1173 L7201 IR REG R7225 R7275 C7223 C7296 C7224 R7226 D7277 C7297 CN7241 D7278 CN7251 R7251 C7281 Q7203 Q7205 D7272 Q7204 D7274 D7271 D7273 R7272 C7285 R7260 C7288 C7283 C7287 C7284 C7286 CN7201 (ANP7835-A) CN7201 SC-68...
Page 238: Connect Assy And Fb-Connect Assy
11.20 CONNECT ASSY and FB-CONNECT ASSY SIDE A CONNECT ASSY AWX1187 J7804 GNDD CONNECT ASSY J7803 GNDD [[ G ]] J7807 V+5R6_EV J7817 V+5R6_EV J7811 J7810 J7818 GNDD GNDD (ANP7836-B) SIDE B CONNECT ASSY (ANP7836-B) SC-68...
Page 239 SIDE A FB-CONNECT ASSY FB-CONNECT ASSY AWX1186 [[ G ]] (ANP7836-B) ANP7836-B) SIDE B FB-CONNECT ASSY (ANP7836-B) (ANP7836-B) SC-68...
Page 240: Pre Bridge, A-Dac Bridge, D-Audio Bridge And D-Dac Bridge Assys
11.21 PRE BRIDGE, A-DAC BRIDGE, D-AUDIO BRIDGE and D-DAC BRIDGE ASSYS SIDE A PRE BRIDGE ASSY [[ G ]] (ANP7835-A) A-DAC BRIDGE ASSY (ANP7825-A) AA AB SC-68...
Page 241 SIDE A D-AUDIO BRIDGE ASSY (ANP7825-A) D-DAC BRIDGE ASSY CN9002 CN9003 CN3784 CN3782 [[ G ]] CN3784 CN3782 A30C5/C7 ¡AWX1128- ¡AWX D-DAC BRIDGE ASSY CN3781 CN3783 (ANP7825-A) CN3781 CN3783 CN2102 CN2101 SC-68...
Page 242 SIDE B D-AUDIO BRIDGE ASSY (ANP7825-A) D-DAC BRIDGE ASSY CN3782 CN3784 CN3782 CN3784 C3780 C3785 C3784 C3781 C3782 C3786 D-DAC BRIDGE ASSY C3787 C3783 CN3781 CN3783 (ANP7825-A) CN3781 CN3783 SC-68...
Page 243 18.GNDDAS 19. SW OUT 20. GNDDAS 21. FL OUT 22.GNDDAS 23.FR OUT 24. GNDDAS 25. FL IN 26.GNDADS 27.FR IN 28. GNDADS 1.V-12_A 2.V-12_A 3.GNDA 4.GNDA 5.V+12_A 6.V+12_A 7.GNDAD 8.GNDAD 9.V+6_AD 10.V+6_AD 11.GNDBT 12.BT R 13.GNDBT 14.BT L (ANP7825-A) SC-68...
Page 244: Front Bridge Assy And Display Bridge Assy
11.GNDHP 12.HPR GNDA J7927 13.GNDHP 14.AMUTE 15.XHPDET J7723 GNDD CN7901 GNDV J7724 GNDV CN7721 CN7901 JH7721 CN7722 (ANP7836-B) CN601 CN7722 CN7721 CN7684 CN7683 SIDE B FRONT BRIDGE ASSY DISPLAY BRIDGE ASSY CN7722 CN7721 CN7901 (ANP7836-B) CN7723 JP7725 AE AF SC-68...
Page 245 SIDE A DISPLAY BRIDGE ASSY [[ G ]] KN7901 J7927 GNDD (ANP7836-B) CN7902 CN3001 SIDE B CN7902 LOW_P (ANP7836-B) Q7901 IC7901 SC-68...
Page 246: F-In Bridge Assy
11.23 F-IN BRIDGE ASSY SIDE A F-IN BRIDGE ASSY CN3472 JP3001 CN7663 CN7664 CN7664 CN7663 [[ G ]] SIDE B F-IN BRIDGE ASSY CN7663 CN7664 SC-68...
Page 247 SIDE A F-IN BRIDGE ASSY AWX1183 G ]] J7166 GNDV J7170 GNDHP CN7661 CN7662 (ANP7836-B) CN7661 CN7662 CN7008 CN7005 SIDE B CN7661 CN7662 C7663 C7662 C7661 R7662 R7164 (ANP7836-B) SC-68...
Page 248: Mch Bridge Assy (Sc-68)
11.24 MCH BRIDGE ASSY (SC-68) SIDE A SIDE A MCH BRIDGE ASSY CN7761 CN2510 CN7672 CN7671 MCH BRIDGE ASSY REAR PANEL [[ G ]] AWX1185 CN7672 CN7671 (ANP7836-B) SIDE B SIDE B MCH BRIDGE ASSY (ANP7836-B) CN7672 CN7671 SC-68...
Page 249: A Reg Bridge Assy
1.V+6_AD [[ G ]] (ANP7835-A) CN5775 JP5775 JP3001 CN7502 SIDE B SIDE B A REG BRIDGE ASSY CN5775 JP5775 [[ G ]] AWX1178 JP5775 CN5775 1.V+6_AD 2.V+12_A 3.GNDA REG BRIDGE ASS'Y 4.GNDA 5.V-12_A 1.V+6_AD 2.V+12_A 3.GNDA 4.GNDA 5.V-12_A (ANP7835-A) SC-68...
Page 250: Mic Hp Guard Assy And Fan Connect Assy
MIC HP GUARD ASSY JH5921 DO NOT THROW! JANGAN BUANG FAN CONNECT ASSY [[ G ]] AWX1197 JH5931 FAN CONNECT Ass'y J5931 J5934 J5937 V+FAN JH5932 J5932 J5935 J5938 V-FAN J5933 J5936 J5939 LOCKDET CN5932 CN5931 (ANP7828-A) AJ AK SC-68...
Page 251 SIDE A AWX1152 UANG MIC HP GUARD Ass'y JH5924 (ANP7828-A) JH5932 (ANP7828-A) SC-68...
Page 252 SIDE B MIC HP GUARD ASSY AWX1152 MIC HP GUARD?@Ass'y FAN CONNECT ASSY AWX1197 FAN CONNECT Ass'y (ANP7828-A) AJ AK SC-68...
Page 253 SIDE B DO NOT THROW! [[ G ]] JANGAN BUANG (ANP7828-A) (ANP7828-A) SC-68...
Page 254: Bind Dm Cable, Bind B Cable, Ffc Guard And Vreg Guard Assys
(ANP7836-B) (ANP7835-A) FFC GUARD ASSY VREG GUARD ASSY [[ G ]] VREG GUARD ASSY [[ G ]] rivet AWX1153 DO NOT THROW! JANGAN BUANG (ANP7828-A) AWX1176 FFC GUARD2 ASS' Y DON'T THROW! JANGAN BUANG (ANP7835-A) AL AM AN AO SC-68...
Page 255 BIND DM CABLE ASSY [[ G ]] AWX1189 BIND DM CABLE Ass'y DO NOT THROW! JANGAN BUANG (ANP7836-B) (ANP7835-A) VREG GUARD ASSY FFC GUARD ASSY VREG GUARD ASSY AWX1153 DO NOT THROW! JANGAN BUANG (ANP7828-A) (ANP7835-A) AL AM AN AO SC-68...
Page 256: Pcb Parts List
5 6 2 1 Mark No. Description Part No. Mark No. Description Part No. LIST OF ASSEMBLIES 1..INTERFACE REG ASSY (SC-67) AWR7155 1..D AMP ASSY (SC-68) AWH7052 2..INTERFACE ASSY AWX1172 2..D AMP ASSY AWX1214 2..IR REG ASSY AWX1173 2..B DIODE ASSY AWX1174 1..D AMP ASSY (SC-67)
Page 257 C1113 CEVW101M16 Not used C1355 VCH1277 CEVW221M4 C1672 ACH7306 Not used C1836 CEVW470M6R3 Not used C1847 CEVW470M6R3 Not used C1934 CFHXSQ103J16 Not used C9583 ACH7306 Not used C9584 CFHXSQ103J16 Not used C9801 CCSSCH100D50 Not used C9807 CCSSCH100D50 Not used SC-68...
Page 258 AWX1218 JA4101 Sp Terminal 6-p(v0) AKE7150 AKE7142 JA4301 Sp Terminal 4-p(v0) AKE7149 AKE7141 JA4501 Sp Terminal 4-p(v0) AKE7149 AKE7141 JA4901 Sp Terminal 4-p(v0) AKE7149 AKE7141 JA5101 Sp Terminal 4-p(v0) AKE7149 AKE7141 R5191 RS1/10SR0R0J Not used R5195 Not used RS1/10SR0R0J SC-68...
Page 259 C 3928,3929,6718-6723 CFHXSQ103J16 Other Resistors RS1/10SR###J C 3945,3951 CCSRCH101J50 CAPACITORS C 6702,6707,6727,6728 CEAK100M50 C 2503,2504,2523,2524 CCSQCH101J50 C 6708 CCSRCH471J50 C 2505,2506,2525,2526 CEAK220M50 C 6710 CKSRYB333K50 C 2507,2508,2679,2680 CEAK101M16 C 6713,6716 CKSRYB473K50 C 2543,2544 CCSQCH101J50 C 6715,6717 CKSRYB104K50 C 2545,2546,2587,2588 CEAK220M50 SC-68...
Page 260 C 2090,2091,2107,2108 CCSRCH102J50 R 2075,2077 RS1/4SA472J R 2100-2103,2132,2138 RS1/4SA222J C 2092-2095,2109-2111 CCSRCH331J50 C 2096,2097,2114,2115 CFHXSQ103J16 R 2115,2119,2238 RS1/16SS101J C 2112,2174,2430 CCSSCH331J50 R 2116-2118,2120 RS1/16SS220J C 2113,2198,2222,2232 CCSRCH331J50 R 2121,2125,2126,2143 RS1/16SS100J C 2116,2117,2239,2247 CEAK100M50 R 2139,2146,2323,2325 RS1/4SA222J R 2141 RS1/16SS103J SC-68...
Page 261 IC 8002 STMPS2171T IC 8003 PCA9517DGK 3652 SCREW IBZ30P080FCC > IC 8004 BD9329EFJ JH 3652 PCB BINDER AEF7008 Q 8004 2SC4154-11 RESISTORS Q 8014,8016 INK0001AC1 R 3652 RS1/4SA105J Q 8015 INJ0003AC1 Other Resistors RS1/8SQ###J D 8004 RKZ5.6KG(B2) D 8005 1SS355 SC-68...
Page 262 C 5648,5666,5675-5678 CKSSYB104K16 C 3667 CKSRYB103K50 C 5649 DCH1201 C 5682,5683 CCSSCH100D50 C 5690 CKSSYB104K16 MULTI CH IN ASSY (SC-68) MISCELLANEOUS JA 7761,7762 RCA JACK AKB7242 DIGITAL MAIN ASSY KN 7761 SCREW PLATE VNE1948 CN 7761 18P SOCKET AKP7123 SEMICONDUCTORS...
Page 263 L 9217 FILTER CTF1703 L 9510-9513,9520,9529 CHIP BEADS ATL7010 R 1103-1105 RS1/16SS5601F L 9519,9527,9533 SMD SPL INDUCTOR ATH7092 R 1214,1215,1339,1342 RAB4CQ330J L 9530 INDUCTOR ATH7087 R 1235,9227 RAB4CQ472J L 9532,9534,9610-9613 CHIP BEADS ATL7010 R 1249,1365,9043,9226 RAB4CQ470J R 1288,1289,1291,9265 RAB4CQ151J SC-68...
Page 264 C 206,627,904,907 CCSSCH471J50 C 1028,1036 CCSSCH270J50 C 222,9422 CKSSYB472K50 C 1032,1038,1039,1047 CKSSYB104K16 C 401,619,623,636 CCSSCH101J50 C 1033,1041,1081,1084 CCSSCH101J50 C 402-404,604,608 CCSSCH100D50 C 1037,1046,1070,1079 CCSSCH331J50 C 405,407,1808,1811 CCG1222 C 1044 CKSSYB823K10 C 406,978,9008,9525 CCSSCH330J50 C 1045,1054,1056,1224 CKSSYB103K25 C 408,428,926,991 CEVW101M4 SC-68...
Page 265 C 9087,9088,9090-9093 CKSSYB104K16 C 1655,1702,1730,1734 CCSSCH101J50 C 9096,9097,9108 CKSSYB104K16 C 1666,1782,1786,1825 CCSSCH471J50 C 9098,9109,9113-9115 CKSSYB103K25 C 1686,1693 CKSRYB103K50 C 9110-9112,9116-9120 CKSSYB104K16 C 1695,1696,1711,1718 DCH1246 C 9121,9125,9127,9128 CKSSYB332K50 C 1701,1721,1725,1754 CCSSCH331J50 C 9122-9124,9144,9171 CKSSYB104K16 C 1713,1719,1723,1728 DCH1201 C 9129,9155,9158,9173 CKSSYB103K25 SC-68...
Page 266 Q 7027-7030 INC2002AC1 C 9528,9537,9538,9553 CKSSYB104K16 D 7005 1SS301 C 9529,9585,9599,9602 CCSSCH331J50 D 7007,7009 1SS357 C 9552,9598,9621,9624 CCSSCH100D50 D 7024 1SS355 C 9559,9561,9581,9592 CCSSCH101J50 D 7026 RB551V-30 C 9590 CCG1222 C 9597,9616,9617,9640 CCSSCH101J50 C 9604,9606,9608,9612 CCSSCH331J50 C 9613,9625,9629,9634 DCH1201 SC-68...
Page 267 1SS302 SEMICONDUCTORS MISCELLANEOUS Q 3601,3604,3605,3608 ISA1602AM1 L 8501 CHIP COIL LCYA330J2520 Q 3602,3603,3606,3607 HN1C01FU JA 8301 6P PIN JACK AU AKB7225 JA 8302,8304,8305 3P PIN JACK AU AKB7228 JA 8601 9P D-SUB SOCKET AKP7256 X 8501 CRYSTAL RESONATOR ASS7080 SC-68...
Page 268 C 3039 ACH7268 C 3488 CKSRYB223K50 C 3043 CCSRCH150J50 C 3490,3497 CCSRCH331J50 C 3048,3058,3101,3207 CCSRCH100D50 C 3495 CKSRYB104K50 C 3103,3105,3201,3204 CKSRYB104K50 C 3104 CCSRCH330J50 C 3208 CEAK221M16 C 3211 ACH7272 C 3212,3221-3223,3303 CCSRCH331J50 C 3213 CEAK101M16 C 3214,3216,3217 CCSRCH221J50 SC-68...
Page 269 CN 3801,3802 B TO B 23PIN JACK AKN7073 CN 3810,3850,3890 B TO B CONNECTOR AKN7155 CN 3820,3830,3840,3860 5P SOCKET KP200IB5L CN 3870,3880 5P SOCKET KP200IB5L IR BUFFER ASSY SEMICONDUCTORS IC 6801,6821,6841,6861 UPC4570G2-A IC 6881,6901,6921,7451 UPC4570G2-A IC 7471 UPC4570G2-A IC 7491 TC4053BFN SC-68...
Page 270 Q 4603-4606,4608 2SC4154-11 R 4102,4103,4202,4203 RS1/10SR1802D Q 4614,4707,4711,4714 ISA1602AM1 R 4104,4105,4204,4205 RS1/10SR9101D Q 4701,4702,4801,4802 IRF6775MPBF > R 4107,4187,4188,4207 ACN7180 Q 4703-4706,4708 2SC4154-11 R 4111,4211,4311,4411 RS1/10SR4700F Q 4803-4806,4808 2SC4154-11 R 4115,4215,4315,4415 ACN7192 Q 4807,4811,4814,4907 ISA1602AM1 R 4116,4190,4216,4290 ACN7199 Q 4900 2SD2704K SC-68...
Page 271 R 4788,4807,4887,4888 ACN7180 R 4495-4498,4586 RS1/8SQR47J R 4795-4798,4886 RS1/8SQR47J R 4500,4501,4600,4601 RS1/10SR5600D R 4800,4801,4900,4901 RS1/10SR6800D R 4502,4503,4602,4603 RS1/10SR1802D R 4819,4822,4823,4867 RS1/10SR1001F R 4504,4505,4604,4605 RS1/10SR9101D R 4895-4898,4986 RS1/8SQR47J R 4507,4587,4588,4607 ACN7180 R 4902,4903 RS1/10SR1802D R 4511,4611,4711,4811 RS1/10SR4700F R 4904,4905 RS1/10SR9101D SC-68...
Page 272 Other Resistors RS1/10SR###J C 4549,4550,4649,4650 ACH7359 C 4556,4656,4756,4856 CKSRYB473K50 CAPACITORS C 4559,4560,4659,4660 ACG7107 C 4007,4011,4013 CCSRCH331J50 C 4561,4575,4661,4675 ACG7105 C 4008,4010,4036,4052 ACH7321 C 4571,4771,4971,5071 CEAK100M50 C 4009,4014-4017,4087 CCSRCH101J50 C 4616,4666,4667,4716 ACH1479 C 4022,4040,4112,4212 CCG1255 C 4621,4622,4709,4714 CFHXSQ103J16 C 4023 CEHVW100M16 SC-68...
Page 273 H 7501-7504,7601-7604 FUSE CLIP AKR1004 HEAT SINK(AL) ANH7224 CN 7501,7601 5P TOP POST B5B-EH HEAT SINK ANH7251 CN 7502 PLUG(5P) KM200NA5 SCREW BBZ30P080FCC CN 7602 PLUG(7P) KM200NA7 JP 51 HOUSING ADX7791 CN 7603 PLUG(4P) KM200NA4 PC 1 PHOTO COUPLER TLP781(GR) > SC-68...
Page 274 CN 7803 B TO B 13PIN JACK AKN7068 H 7251-7254 FUSE CLIP AKR1004 CN 7804 B TO B 19PIN JACK AKN7071 CN 7201 8P TOP POST B8B-EH CN 7241 PLUG(2P) KM200NA2 RESISTORS CN 7251 PLUG(7P) KM200NA7 R 7804,7805 RS1/8SQ105J Other Resistors RS1/10SR###J SC-68...
Page 275 RESISTORS CN 3781,3782 B TO B CONNECTOR AKM7176 R 7667 RS1/4SA105J CN 3783,3784 PLUG (30P) BKM1035 Other Resistors RS1/10SR###J CAPACITORS CAPACITORS C 3780 CCSRCH100D50 C 7168,7175 CCSRCH101J50 C 3784 CKSRYB104K50 C 7171 CCSRCH330J50 C 3785 CKSRYB103K50 C 3786 CCSRCH101J50 SC-68...
Page 276 Mark No. Description Part No. MCH BRIDGE ASSY (SC-68) MISCELLANEOUS CN 7671,7672 18P PLUG AKM7050 A REG BRIDGE ASSY MISCELLANEOUS CN 5775 PLUG(5P) KM200NA5 JH 5775,5776 PCB BINDER AEF7008 JP 5775 HOUSING ADX7773 RESISTORS All Resistors RS1/10SR###J MIC HP GUARD ASSY...

This manual is also suitable for:

Sc-67

Pioneer SC-68 Service Manual

Quick Links

Related Manuals for Pioneer SC-68

Summary of Contents for Pioneer SC-68

This manual is also suitable for:

Table of Contents