Advertisement
Advertisement
Table of Contents
Related Manuals for AEG AGN6000DB
Summary of Contents for AEG AGN6000DB
- Page 1 AGN6000DB PORTABLE GENERATOR SET Original Instructions...
- Page 2 carburetor circuit breaker drain screW engine sWitch Fig. 1 Fig. 2 fuel tank fuel cap fuel level gauge choke lever oil cap/ dipstick oil drainage bolt filter fuel valve recoil starter grip Fig. 3 fuel tank fuel cap fuel fuel level gauge level gauge oil cap/...
- Page 3 recoil starter grip Fig. 6 choke lever to start (choke closed) to run fuel valve (choke open) Fig. 7 Fig. 8 filter elements latches air filter unit filter cover Fig. 9...
- Page 4 oil cap/ dipstick Fig. 10 spark plug fuel valve filter o-ring sediment spark plug Fig. 11 Fig. 12 fuel fuel line valve barb Fig. 13...
-
Page 5: Important Safety Instructions
English INTRODUCTION Do not touch bare wire or receptacles. Do not use the generator with electrical cords which are This product has many features for making its use more pleasant worn, frayed, bare, or otherwise damaged. and enjoyable. Safety, performance, and dependability have Before storing, allow the engine to cool. -
Page 6: Specific Safety Rules
English spECIfIC sAfETy RULEs Do not touch the muffler or cylinder during or immediately after use; they are HOT and will cause burn injury. WARNING: When this generator is used to supply a building Do not connect to a building’s electrical system unless a wiring system: the generator must be installed by transfer switch has been properly installed by a qualified a qualified electrician and connected to a transfer... - Page 7 English symBOLs Some of the following symbols may be used on this tool. Please study them and learn their meaning. Proper interpretation of these symbols will allow you to operate the tool better and safer. symBOL NAmE DEsIGNATION/EXpLANATION Volts Voltage Amperes Current Hertz...
- Page 8 English symBOLs The following signal words and meanings are intended to explain the levels of risk associated with this product. symBOL sIGNAL mEANING Indicates an imminently hazardous situation, which, if not avoided, will result in death DANGER: or serious injury. Indicates a potentially hazardous situation, which, if not avoided, could result in death WARNING: or serious injury.
-
Page 9: Safety Labels
English symBOLs sAfETy LABELs HOT sURfACE WARNING The information below can be found on the generator. For Do not touch the muffler or aluminum cylinder of the engine. your safety, please study and understand all of the labels They are very HOT and will cause severe burns. Don’t put before starting the generator. -
Page 10: Generator Capacity
English CAUTION: ELECTRICAL Do not overload the generator’s capacity. Exceeding the generator’s wattage/amperage capacity can damage the GENERATOR CApACITy generator and/or electrical devices connected to it. Make sure the generator can supply enough continuous (running) and surge (starting) watts for the items you will power at the Typical Typical surge same time. - Page 11 English fEATUREs model AGN6000DB Alternator Type Brush alternator with AVR AC Frequency (Hz) AC Output voltage (V) Rated AC Output (W) 5,000 Rated Current (A) 20.9 Circuit Breaker (A) Power Factor Volts Amps Engine Number UP188 Engine Type 4-Stroke; air-cooled OHV; Unleaded fuel...
- Page 12 English fEATUREs RECEpTACLEs Your generator has the following single phase, 50 Hz outlets: one 230 Volt AC, 16 Amp receptacle. These can be used for KNOW yOUR GENERATOR operating appropriate appliances, electrical lighting, tools, and See Figure 3. motor loads. The safe use of this product requires an understanding of the information on the product and in this operator’s manual as well RECOIL sTARTER GRIp...
-
Page 13: Operation
English WARNING: WARNING: If any parts are damaged or missing do not operate Do not use any attachments or accessories not this product until the parts are replaced. Failure to recommended by the manufacturer of this product. heed this warning could result in serious personal The use of attachments or accessories not injury. - Page 14 English UsING fUEL sTABILIsER Connecting the battery cables: Before connecting the battery charging cables to Fuel gets old, oxidizes, and breaks down over time. Adding a a battery that is installed in a vehicle, disconnect the fuel stabiliser extends the usable life of fuel and helps prevent vehicle ground battery cable from the battery negative (-) deposits from forming that can clog the fuel system.
-
Page 15: Maintenance
English sTARTING THE ENGINE ( ELECTRIC ) Replace the elements in the air filter unit. Turn the fuel valve to the ON position. Replace the air filter cover and close latches to secure. Turn the key to “START” position and release. NOTE: Do not run the generator without the air filter. -
Page 16: Spark Arrestor
English Seat spark plug in position; thread in by hand to prevent DRAINING THE CARBURETOR cross-threading. See Figure 2. Tighten with wrench to compress washer. If spark plug Turn the engine switch off ( O ). is new, use 1/2 turn to compress washer appropriate Close the fuel valve. -
Page 17: Storage Time
English mAINTENANCE sTORAGE When preparing the generator for storage, follow the guidelines below. sTORAGE TImE pRIOR TO sTORING No special preparation is required. Less than 1 month Empty fuel from fuel tank. 1 to 2 months Empty fuel from fuel tank. 2 months to 1 year Drain fuel from carburetor. - Page 18 English mAINTENANCE pROBLEm pOssIBLE CAUsE sOLUTION Engine will not start. Engine switch is OFF. Turn engine switch to ON. No fuel. Fill fuel tank. Oil level is low. Check engine oil level and fill, if necessary. Turn fuel valve ON. Fuel valve is OFF.
- Page 19 English...
-
Page 20: Limited Warranty
LImITED WARRANTy TTI warrants this outdoor product to be free of defects in material and workmanship for 24 months from the date of purchase by the original purchaser, subject to the limitations below. Please keep your invoice as proof of date of purchase. This warranty is only applicable where the product is used for personal and non-commercial purposes. - Page 21 Tsuen Wan, Hong Kong. Tel.: (+45) 43 56 55 55 Tel : + 852 2402 6888 Fax: (+45) 43 56 55 56 Machine: portable Generator set Type: AGN6000DB Name of company: Homelite Far East Co., Ltd. Name / title: Sven Eschrich Address:...