Related Manuals for Cadel Martina
Summary of Contents for Cadel Martina
- Page 1 ©2013 CADEL srl | All rights reserved – tutti i diritti riservati...
-
Page 2: Table Of Contents
9.3 OVERALL DIMENSIONS (SOLARIS MODEL) ..14 13.2 PROBLEM SOLVING ........32 9.4 GENERAL INSTALLATION ......15 14 TECHNICAL DATAS ........34 9.5 SIDE PANEL ASSEMBLY (MARTINA MODELS) ...15 14.1 REPAIR INFORMATION .......34 9.6 ELECTRIC CONNECTION ......16 14.2 FEATURES ............35 9.7 CONNECTION TO THE EXTERNAL THERMOSTAT ..17 9.8 VENTILATION ..........17... -
Page 3: Manual Simbology
(“system” means: stove + chimney + air inlet). • According to (EU) No. 305/2011 regulation, the “ Declaration of Performance” is available online at the web sites www.cadelsrl.com / www.free-point.it. MARTINA - VANESSA - ALESSIA - SOLARIS... -
Page 4: Cautions
• do not turn the stove upside down and/or upset it on one side, but keep it in vertical position or as accorded with the constructor instructions; • if the stove is made up of ceramic, stone, glass or any particularly fragile material components, all must be moved with the utmost care. MARTINA - VANESSA - ALESSIA - SOLARIS... -
Page 5: Chimney Flue
• Both this solutions must be endowed with an inspection plug (3) and/or an inspection door (4). It is forbidden to connect more pellet stoves or any other heating appliance to the same chimney flue. MARTINA - VANESSA - ALESSIA - SOLARIS... -
Page 6: Technical Features
• The flue system must be placed on the roof. • The chimney flue must be provided CE in accordance with EN 1443 regulation. Please find attached an example of label: Fig. 4 - Example of label MARTINA - VANESSA - ALESSIA - SOLARIS... -
Page 7: Height-Depression
• It should prevent the infiltration of rain, snow and animals. • The outlet height in the atmosphere must be away from the reflux area caused by the roof structure or by obstacles laying nearby (see Fig. 3 page 6). MARTINA - VANESSA - ALESSIA - SOLARIS... -
Page 8: Chimney Components
Chimney flue Termal insulation External wall Chimney union Fume pipe Heat generator Inspection door T-union with inspection plug EXTERNAL AIR INLET Fig. 7 - Direct air inflow Fig. 8 - Indirect air inflow MARTINA - VANESSA - ALESSIA - SOLARIS... -
Page 9: Chimney Flue Connection
• It is forbidden to connect any other appliance (wood stoves, cooker hoods, boilers, etc...). • The fume conduit must be placed at a distance of minimum 500 mm from flammable or heat-susceptible components. MARTINA - VANESSA - ALESSIA - SOLARIS... -
Page 10: Examples Of Correct Installation
Minimum safety distance = 0,5 mt Inclination ≥ 3° Level section ≤ 1 mt • Old chimney flue with an inserted pipe of minimum Ø120 mm and with an external door which enables the chimney cleaning. MARTINA - VANESSA - ALESSIA - SOLARIS... -
Page 11: Fuel
(auger) there could exist minimum differences in the material used, in roughness and porosity, which could generate usual variations in fuel transportation (pellets), causing a flame raising or drapping with MARTINA - VANESSA - ALESSIA - SOLARIS... -
Page 12: Installation
• In any case the stove must not be installed in rooms where it can get in touch with water or water splashes because this can cause burn hazards and short-circuit. • To install more appliances, the external air inlet must be correctly dimensioned (see EXTERNAL AIR INLET page MARTINA - VANESSA - ALESSIA - SOLARIS... -
Page 13: Overall Dimensions (Martina-Vanessa-Alessia Models)
Fig. 12 - General dimensions LEGEND Fig. 12 page 13 57 cm 98 cm 52 cm 38,5 cm 36,7 cm 29 cm 28 cm Hole combustion air inlet d.4 cm Exhaust fumes d.8 cm MARTINA - VANESSA - ALESSIA - SOLARIS... -
Page 14: Overall Dimensions (Solaris Model)
Fig. 13 - General dimensions LEGEND Fig. 13 page 14 52,6 cm 121,6 cm 53,6 cm 38,5 cm 36,7 cm 29 cm 28 cm Hole combustion air inlet d.4 cm Exhaust fumes d.8 cm MARTINA - VANESSA - ALESSIA - SOLARIS... -
Page 15: General Installation
Fig. 15 - Upper screws removal Fig. 16 - Backward screws removal • Remove the top cover: unscrew the 2 upper screws and the 3 backward screws (see Fig. 15 page 15 and Fig. 16 page 15). MARTINA - VANESSA - ALESSIA - SOLARIS... -
Page 16: Electric Connection
• The plug must be easily accessible when the appliance is installed. The cable must not get in touch with the fume exhaust pipe and nor with every other part of the stove. MARTINA - VANESSA - ALESSIA - SOLARIS... -
Page 17: Connection To The External Thermostat
Childreen must be constantly overseen in order to assure that they do not play with the appliance. MARTINA - VANESSA - ALESSIA - SOLARIS... -
Page 18: Introduction
P4: ignition and shut down, unblocking from probable alarms and exit from programming. P5 e P6: increase and decrease the calorific power from 1 to 5. Hourly programming: acitvated. Auger: activated. Remote control data reception MARTINA - VANESSA - ALESSIA - SOLARIS... -
Page 19: Ignition
• If the flame is weak and the glass tends to blackens, this means that the combustion is not correct: it is necessary to open the regulator (see Fig. 22 page 20). MARTINA - VANESSA - ALESSIA - SOLARIS... -
Page 20: Failed Ignition
To switch the stove off, keep pressed P4 key: the display A shows “OFF”. After about 15-20 minutes also the fume fan switches off (this occurs always wheter the stove is hot or cold). MARTINA - VANESSA - ALESSIA - SOLARIS... -
Page 21: Clock Setting
In case it would be necessary to extinguish the fire emitted by the stove or by the chimney flue, use a fire- extinguisher or contact the firemen. DO NOT use water to extinguish the fire inside the burning pot. MARTINA - VANESSA - ALESSIA - SOLARIS... -
Page 22: Pellet Supply
Button 5 Decrease the power level from 5 to 1 Button 6 Increase the power level from 1 to 5 Buttons 1 and 6 Pressed together enable to turn the stove on and off MARTINA - VANESSA - ALESSIA - SOLARIS... -
Page 23: Safety System
• Reset the error with P4 key. • Check the type of glitch as provided by ALARMS page 29. • Clean the burning pot and start the stove up again with P4 key. MARTINA - VANESSA - ALESSIA - SOLARIS... -
Page 24: Alar Sic" Alarm
• Extract the burning pot from its seat and empty it from the ash. • Extract the ash tray and empty it from the ash. • If necessary clean with a pointed object the holes obstructed by encrustations (see Fig. 26 page 24). MARTINA - VANESSA - ALESSIA - SOLARIS... -
Page 25: Hopper And Auger Cleaning
DO NOT remove the hand rejector and DO NOT touch the auger. Please contact the Technical Assistance service. The hand rejector can be removed exclusively by an authorized technician. 12.4 FUME CHAMBER CLEANING Every 4/8 weeks the fume chamber cleaning must be executed. MARTINA - VANESSA - ALESSIA - SOLARIS... -
Page 26: Fume Conduit Cleaning
Clean every the year the fume fan from ash or dust which can cause a blade unbalance and a greater noise. As this operation is so delicate it must therefore be executed by an Authorized Technician. MARTINA - VANESSA - ALESSIA - SOLARIS... -
Page 27: Room Fan Cleaning
This operation must be executed at least once a year. 12.9 GENERAL CLEANING For cleaning external and inner parts of the stove do not use steel wools, muriatic acid or other corrosive and abrasive materials. MARTINA - VANESSA - ALESSIA - SOLARIS... -
Page 28: Cleaning Of Painted Metal Panels
The glass-ceramic of the fire door is able to stand till 700°C but not to thermal shocks. The probable cleaning with usual sale product for glass cleaning must be effected at cool glass in order to avoid explosions. You should clean the fire door glass every day! MARTINA - VANESSA - ALESSIA - SOLARIS... -
Page 29: In Case Of Anomaly
Replace the fume probe. Faulty mother board Replace the electronic board. ALAR HOT TEMP The ambient exchanger Replace the ambient fan. fan does not work To high pellet drop value Control the pellet drop. “phase 5” MARTINA - VANESSA - ALESSIA - SOLARIS... - Page 30 Too severe external Start the stove up again. temperature Humid pellets Check if the pellet is stored in a dry place. Blocked thermal probe Replace the thermal probe. Faulty mother board Replace the mother board. MARTINA - VANESSA - ALESSIA - SOLARIS...
- Page 31 CHIMNEY FLUE page 5 Adverse wheather In case of strong wind there can be a negative pressure conditions to the chimney. Check it and switch the stove on again. MARTINA - VANESSA - ALESSIA - SOLARIS...
-
Page 32: Problem Solving
Auger geared motor out Replace the geared motor. of order Check on the display if there is an active alarm Have the stove overhauled. (“ALAR DEP”, “ALAR SIC”) MARTINA - VANESSA - ALESSIA - SOLARIS... - Page 33 It can be harmful to health to run the stove without fume fan. Faulty fume temperature Heat Replace the fume probe. probe exchanger fan keeps turning even when the stove has Faulty electronic board Replace the mother board. cooled MARTINA - VANESSA - ALESSIA - SOLARIS...
-
Page 34: Technical Datas
To reassemble all proceed opposite. MARTINA - VANESSA - ALESSIA - SOLARIS... -
Page 35: Features
300 W 300 W 300 W 300 W MINIMUM EXTERNAL AIR INLET (last 80 cm 80 cm 80 cm 80 cm effective area) STOVE WITH SEALED CHAMBER EXTERNAL AIR INLET FOR SEALED CHAMBER MARTINA - VANESSA - ALESSIA - SOLARIS... - Page 36 · thermostoves pellet fireplace inserts · · pelletkachels houtkachels houtkeukens · thermokachel open haard pellets CADEL srl FREEPOINT by Cadel Via Foresto Sud, 7 31025 Santa Lucia di Piave (TV) - ITALY tel. +39.0438.738669 fax +39.0438.73343 www.cadelsrl.com Partner of:...